Mikasa 454100, Инструкция по эксплуатации

Страница: 29 / 40

3
4
5
6
●
●
●
1
2
3
4
24
11.8 Battery
How to remove the battery
Remove the stopper at the two locations
on the top portion of the rear cover to
open the rear cover.(Fig.51)
Loosen, but not remove, the M8 bolts (2
bolts) used for cyclone cleaner attach-
ment. Take out the cyclone cleaner down-
ward.(Fig.52)
Take off the nuts and remove the battery
holder. After tilting the battery backward,
disconnect the battery terminal. When
doing so, always disconnect the black ter-
minal on the minus side first.
By holding the top surface handle, pull
upward to remove the battery from the
machine.(Fig.53)
If an old battery is used, even when the bat-
tery checker is not lighted (indicating charging
level low), the cell starter might not operate
because of low charging level. If that hap-
pens, change the battery with the new one.
Pay sufficient attention so that the battery ter-
minal will not touch the frame.
Pour hydraulic oil(550cc) from the hand
pump breather plug attachment hole.
(Fig.47)
Remove the air releasing plug of vibrator
cylinder. Then oil will come out from the
air releasing plug. After air bubbles stop
coming out, attach the plug. Tighten se-
curely. (Fig.48)
Then release the direction control lever
and move the lever forward and reverse
several dozen times (until air bubble not
be found). Stay the lever at the forward
position for 10 seconds every time.
(Because the check valve is opened at the
maximum forward position and air bubble
will come out from the oil tank of the hand
pump).(Fig.49)
In case the air bleeding is insufficient,
repeat the procedure of above “4” and “5”.
Attach the hand pump breather plug, put
on the plug cap. After making sure the hy-
draulic oil in the pump is at OIL LEVEL,
attach the breather plug.
Hydraulic oil:
Shell Terrace Oil #32 or equivalent
Checking the battery
The standard battery installed is a mainte-
nance free battery. It is not necessary to
supply battery fluid. In case of a sudden
voltage drop, the battery cannot be
charged quickly, so it has to be replaced
with a new one.
Check of battery capacity by battery
checker
When the battery charging level gets low,
the battery checker of the hour tachometer
lights up in red.(Fig.50)
The level of the hydraulic oil in the hand pump
should always be at OIL LEVEL. If the level is
higher, the oil bursts out from the breather plug.
CAUTION
！
CAUTION
！
CAUTION
！
Fig.51
Rear cover
Stopper
Fig.50
DIESEL
ENGINE TACH &HOUR METER
Battery checker
HOUR TACHOMETER
Fig.52
M8 bolts (2 bolts)
CUT
Cyclone cleaner