Meyer's M3230 Tandem, Инструкция и каталог запасных частей

Страница: 13 / 52

M o d e l M 3 2 3 0 13 | P a g e
TRACTOR TOWING SIZE REQUIREMENTS
The spreader does not have brakes, towing the spreader must be done safely. The ASAE (American Society of
Agricultural Engineers) specifies that the towing vehicle should weigh at least 2/3 as much as the loaded
implement to be reasonably safe towing at speeds up to 20 mph. This (20 mph) is also the maximum
recommended towing speed for the spreader.
The loaded weight of your spreader will naturally vary with the moisture of the manure and you must consider that
for your conditions. The loaded weight as specified by the spreader manufacturer is as follows:
Use the following charts for calculating spreader gross weight and minimum tractor weight:
HYDRAULIC SYSTEM
There are two hydraulic circuits on the spreader:
1. One circuit powers the hydraulic end gate.
2. The second circuit powers the hydraulic apron drive. A check valve is installed in this circuit to prevent
operating the apron in reverse.
Therefore, the tractor requires two sets of remote ports with a minimum recommended flow of 12 GPM.
The spreader comes standard with a Manual Flow Control system for operating the apron. The system has an
adjustable flow control valve on the spreader which is manually controlled by twisting the
“control hose.”
The hose is connected to the flow control valve on the spreader and the opposite end of the hose is fitted with a
handle to operate from the tractor seat. The flow control lever on the spreader has a tension screw adjustment to
regulate force to retain settings. See Figure 3 on Page 14.
LOAD TYPE CAPACITY
Struck Level 200 ft
3
Heaped 310 ft
3
Calculations
Load Weight Capacity (ft
3
) x Material Weight (lbs. / ft
3
) = Load Weight
Spreader Gross Weight Empty Weight (7300 lbs) + Load Weight = Gross Weight
Minimum Tractor Weight Spreader Gross Weight x (2/3) = Min Tractor Weight
ESTIMATED WEIGHTS PER CUBIC FOOT
Material LBS / FT
3
Lime Sludge 110-115 LBS.
Dry Feedlot Manure 63-65 LBS.
Chicken Litter 63-65 LBS.
Cake Sludge 62-65 LBS.
Semi-Solid Manure 58-60 LBS.
Pen Packed Manure 30-35 LBS.
Liquid Manure 63-65 LBS.
NOTICE!
HEAPED LOADS HAVE SIGNIFICANTLY
HIGHER CAPACITIES RESULTING IN
INCREASED WEIGHT AND HIGHER CENTER
OF GRAVITY, REQUIRING EXTRA
PRECAUTION DURING OPERATION.
EXAMPLE
A heaped load of pen packed manure:
Load Weight = 310 x 35 = 10850 LBS
Gross Weight = 6,000 + 10850 = 16,850 LBS
Tractor Weight = 16850 x (2/3) = 11,233 LBS