Mahindra JINMA-200, Руководство по эксплуатации

Страница: 18 / 73

13
4) Stopping the tractor
A. Throttle the engine down to lower the speed of the tractor.
B. Depress the clutch pedal quickly and shift the gear-shifting lever to neutral position.
C. Release the clutch pedal and let engine run idle.
D. Depress the brake pedals to stop the tractor, then lock the pedals with the lock pawl.
Note:
In case the tractor has to be stopped suddenly, clutch pedals and brake pedals
should bedepressed simultaneously. It is prohibited to depress the brake pedals only, which
will damage the parts.
E. If the tractor is to be parked for quite a while, the engine should be stopped. After the
engine has been unloaded, it should run at low speed for some time until the cooling water
temperature drops to
℃
70 or lower, then pull out fuel cut-off rod to bring the engine to a stop.
Note:
It is prohibited to stop the engine at once when its temperature is very high, or to
stop the engine with decompression mechanism.
F.Turn the preheating/starting switch to "O" and pull out the key. If the tractor is going
to be stored, turn off the fuel tank cock.
℃
G.If the tractor is stopped when the ambient temperature is below 0 , screw of the
radiator cap and turn on the water-drain cock on the bottom of the radiator and on the
cylinder block to drain out water at idle engine speed so as to protect the body and radiator
from being frozen (not includingadding anti-icing fluid).
5) Safety regulations for operation
Safety regulations are very important for protecting drivers and tractors from hazard.
They should be observed strictly in operation.
A. Inspect carefully the working condition of the engine and main components, and listen
to whether there is abnormal sound or noise. Especially observe the technical state of clutch
and brake. Check and tighten the bolts and nuts on main components of the tractor.
B. Make sure that there is no people or obstacle around the tractor and press horn
button beforestarting off the tractor.
C. Don't go up and down the tractor during running. Never make check or repair under
the tractor while the engine is still running.
D. Before the tractor goes up or down a slope, proper speed should be selected and don't
coast, turn sharply or shift gears while driving down a slope.
E. In transportation, left and right brake pedals must be locked together. One-side
braking can not be used for sharp turning when the tractor is running at high speed or with
full load.