Instruction manual
11
TO CHECK FOR LEAKS
Make 2-3 fluid ounces of leak detecting solution by mixing one part washing up liquid with 3 parts water.
Ensure the control valve is “OFF”.
Connect the regulator to the cylinder and connect regulator with hose and outdoor gas grill, ensure the
connections are secure then turn ON the gas.
Brush the soapy solution on to the hose and all joints. If bubbles appear you have a leak, which must be
rectified before use.Turn off the gas supply in the event of gas leak.
Retest after fixing the fault. Turn OFF the gas at the cylinder after testing.
If detected leakage cannot be rectified, do not attempt to cure leakage but consult your gas dealer.
REGULATOR AND HOSE
Use only regulators and hose approved for LPG at the above pressures (See Page 6). The life expectancy
of the regulator is estimated as 10 years. It is recommended that the regulator is changed within 10 years
of the date of manufacture.
The use of the wrong regulator or hose is unsafe; always check that you have the correct items before
operating the barbecue.
The hose used must conform to the relevant standard for the country of use. The length of the hose must
be 1.5 meters (maximum). Worn or damaged hose must be replaced. Ensure that the hose is not
obstructed, kinked, or in contact with any part of the barbecue other than at its connection.
Change
the hose when the national conditions require it and/or depending on it validity.
The hose should not be twisted or kinked when attached to the regulator and outdoor gas grill. No part of
the hose should touch any part of the appliance. So site the cylinder out to the left hand side of the
appliance at the maximum distant permitted by the hose length.
STORAGE OF THE APPLIANCE
Storage of an appliance indoors is only permissible if the cylinder is disconnected and removed from the
appliance. When the appliance is not to be used for a period of time it should be stored in a dry dust free
environment.
GAS CYLINDER
The appliance can be used with any gas cylinder of weights between 4.5KGS and 15KGS butane and 3.9KGS
to 13KGS propane. The gas cylinder should not be dropped or handled roughly! If the appliance is not in
use, the cylinder must be disconnected. Replace the protective cap on the cylinder after disconnecting the
cylinder from the appliance. The maximum weight of cylinder is 6.75KGS.
Cylinders must be stored outdoors in an upright position and out of the reach of children. The cylinder
must never be stored where temperatures can reach over 50
°
C. Do not store the cylinder near flames,
pilot lights or other sources of ignition. DO NOT SMOKE.The cylinder should be changed away from any
source of ignition.
