13
7. STORAGE OF ENGINE
Should the engine be stored for a long period, please do as follows:
①
Drain off the fuel in tank and oil in crankcase;
②
Remove the spark plug, add about 2-3 cc. Engine oil into the cylinder, and reinstall
the spark plug. Pull the recoil until feeling the compression. At this time, both the inlet
and exhaust valve are close to prevent the engine chamber from rusting;
③
Clean the surface of engine with clean cotton;
④
Store the engine in dry and dust free area.
⑤
Electric starter: Disconnect the battery, change the battery once every mouth.
8. TROUBLE SHOOTING
Starting failure:
①
Is ignition normal?
·
Is engine switch turn to "ON" position?
·
Remove the spark plug, when it is soiled, clean or replace it.
②
Is compression sufficient?
·
Confirm 6x pulling the starter handle slowly. When compression is insufficient,
check whether tightening of spark plug is firm. If it is loose, tighten.
③
Is fuel sucked into the combustion chamber?
·
Is fuel cock open?
·
Close chock lever, pull the starter handle several times ,then remove the spark
plug. When the tip of spark plug is wet, it is OK.
·
When fuel is not sucked, check fuel strainer for clogging.
·
When engine does not start though fuel is sucked, replace fuel with new.
When the engine does not start in spite of above mentioned inspections, ask the
distributor or repair factory for inspection.
