19
KOHLER CO.
FEDERAL AND CALIFORNIA EMISSION CONTROL SYSTEMS
LIMITED WARRANTY
SMALL OFF-ROAD ENGINES
The U.S. Environmental Protection Agency (EPA), the California Air Resources Board (CARB), and Kohler Co. are pleased to explain the
Federal and California Emission Control Systems Warranty on your small off-road equipment engine. For California, engines produced in
1995 and later must be designed, built and equipped to meet the state’s stringent anti-smog standards. In other states, 1997 and later
model year engines must be designed, built and equipped, to meet the U.S. EPA regulations for small non-road engines. The engine must
be free from defects in materials and workmanship which cause it to fail to conform with U.S. EPA standards for the first two years of
engine use from the date of sale to the ultimate purchaser. Kohler Co. must warrant the emission control system on the engine for the
period of time listed above, provided there has been no abuse, neglect or improper maintenance.
The emission control system may include parts such as the carburetor or fuel injection system, the ignition system, and catalytic converter.
Also included are the hoses, belts and connectors and other emission related assemblies.
Where a warrantable condition exists, Kohler Co. will repair the engine at no cost, including diagnosis (if the diagnostic work is performed at
an authorized dealer), parts and labor.
MANUFACTURER’S WARRANTY COVERAGE
Engines produced in 1995 or later are warranted for two years in California. In other states, 1997 and later model year engines are
warranted for two years. If any emission related part on the engine is defective, the part will be repaired or replaced by Kohler Co. free of
charge.
OWNER’S WARRANTY RESPONSIBILITIES
(a)
The engine owner is responsible for the performance of the required maintenance listed in the owner’s manual. Kohler Co.
recommends that you retain all receipts covering maintenance on the engine, But Kohler Co. cannot deny warranty solely for the lack
of receipts or for your failure to assure that all scheduled maintenance was performed.
(b)
Be aware, however, that Kohler Co. may deny warranty coverage if the engine or a part has failed due to abuse, neglect, improper
maintenance or unapproved modifications.
(c)
For warranty repairs, the engine must be presented to a Kohler Co. service center as soon as a problem exists. Call
1-800-544-2444 or access our web site at: www.kohlerengines.com for the names of the nearest service centers. The warranty
repairs should be completed in a reasonable amount of time, not to exceed 30 days.
If you have any questions regarding warranty rights and responsibilities, you should contact Kohler Co. at 1-920-457-4441 and ask for an
Engine Service representative.
COVERAGE
Kohler Co. warrants to the ultimate purchaser and each subsequent purchaser that the engine will be designed, built and equipped, at the
time of sale, to meet all applicable regulations. Kohler Co. also warrants to the initial purchaser and each subsequent purchaser, that the
engine is free from defects in materials and workmanship which cause the engine to fail to conform with applicable regulations for a period
of two years.
Engines produced in 1995 or later are warranted for two years in California. For 1997 and later model years, EPA requires manufacturers to
warrant engines for two years in all other states. These warranty periods will begin on the date the engine is purchased by the initial
purchaser. If any emission related part on the engine is defective, the part will be replaced by Kohler Co. at no cost to the owner. Kohler Co.
is liable for damages to other engine components caused by the failure of a warranted part still under warranty.
Kohler Co. shall remedy warranty defects at any authorized Kohler Co. engine dealer or warranty station. Warranty repair work done at an
authorized dealer or warranty station shall be free of charge to the owner if such work determines that a warranted part is defective.
Listed below are the parts covered by the Federal and California Emission Control Systems Warranty. Some parts listed below may require
scheduled maintenance and are warranted up to the first scheduled replacement point for that part. The warranted parts are:
•
Oxygen sensor (if equipped)
•
Ignition module(s) with high tension lead
•
Intake manifold (if equipped)
•
Gaseous fuel regulator (if equipped)
•
Exhaust manifold (if equipped)
•
Electronic control unit (if equipped)
•
Catalytic muffler (if equipped)
•
Carburetor or fuel injection system
•
Fuel metering valve (if equipped)
•
Fuel lines (if equipped)
•
Spark advance module (if equipped)
•
Air filter, fuel filter, and spark plugs (only
•
Crankcase breather
to first scheduled replacement point)
Continued on next page.
