Hyundai HY50, Руководство пользователя

Страница: 19 / 24

8. TROUBLESHOOTING
8.1. Engine.
Engine will not start Cause Corrective measure
Check controls
Fuel Valve 'OFF' Move fuel valve lever to 'ON' position
Choke 'OPEN'
Move the choke lever to the 'CLOSED'
position unless the engine is warm
Engine Switch 'OFF' Turn engine switch to 'ON'
Check Fuel
Out of Fuel Refuel
Bad fuel, pump has been stored
without treating or draining fuel or
refueling with bad fuel
Drain the fuel tank and carburetor and,
refuel with fresh fuel
Remove and inspect the spark plug
Faulty spark plug or improperly gapped Adjust gap or replace with a new spark
plug
Spark plug wet with fuel, flooded
engine
Dry spark plug and reinstall. Start
engine with throttle lever in 'FAST'
Contact dealer
Fuel filter clogged, carburetor
malfunction, ignition malfunction,
valves stuck etc.
Return to dealer for repair
8.2. Water pump.
No output from pump Cause Corrective measure
Check pump chamber Pump not primed Prime pump
Check suction hose
Hose collapsed, cut or punctured Replace hose
Strainer not completely under water
Sink strainer and end of suction hose
completely under water
Air leak at connector
Replace sealing washer if it is missing or
damaged. Tighten hose connector and
clamp
Strainer clogged Clear debris from strainer
Measure suction and discharge head Excessive head Relocate pump and hose to reduce head
Check engine Engine lack power See engine troubleshooting above
Low pump outlet Cause Corrective action
Check suction hose
Hose collapsed, cut or punctured Replace hose
Strainer not completely under water
Sink strainer and end of suction hose
completely under water
Air leak at connector
Replace sealing washer if it is missing or
damaged. Tighten hose connector and
clamp
Strainer clogged Clear debris from strainer
Check discharge hose
Hose damaged, too long or diameter too
small
Replace discharge hose
Measure suction and discharge head Excessive head Relocate pump and hose to reduce head
Check engine Engine lack power See engine troubleshooting above
Rev 6 - 10/11/2015