HSR S4 Standup 2007, Руководство по обслуживанию

Страница: 9 / 134

1.7. Service Guidelines - Safety Warnings
Clean inside and outside of watercraft prior to servicing.
Clean all parts before installing.
Always use a service apron to prevent damage to foot well and top- deck fiberglass.
Watch for sharp edges which can cause personal injury.
Protect hands and arms when working with sharp components.
Always use a soft- faced hammer and extreme care when removing difficult or stuck
components.
Some fasteners are installed with locking agents or lubricants. Use of impact drivers will aid
in fastener removal.
Always follow torques specifications located throughout manual.
Fasteners secured with either too little or too much torque may fail and cause severe
property damage, injury or death.
Always follow torque sequence patterns when founding this manual.
Tighten each fastener evenly and to the specified torque value, and with specified locking
agent.
Always use new gaskets, o- rings and seals, clips, cir- clips, and snap rings when
assembling components.
Never reuse Nylokt or Flex Lockt nuts when assembling components.
Never reuse Oetikert clamps when removed from fuel lines. Replace with small gear clamps.
Always use Hydrospace authorized lubricants, greases, and locking agents when assembling
components. Failure to do so may cause severe engine or vehicle damage.
Always disconnect the black (- ) negative cable first from the battery when removing the
battery. When installing the battery, attach the red (+) positive cable first, then the black (- )
negative cable.
Wear appropriate clothing, eye protection, and rubber gloves when working with batteries.
Battery acid contains sulphuric acid and is extremely poisonous. Serious burns can result
when in contact with skin, clothing, eyes or internal body components. If battery acid is
ingested, drink large quantities of water or milk. Follow with milk of magnesia, beaten egg or
vegetable oil. Call a physician immediately. Flush eyes for15minutes with water and seek
prompt medical attention if acid comes in contact with eyes. Thoroughly wash affected
external body parts that come in contact with battery acid with water.
Keep hands, arms, legs, feet and hair away from rotating parts, hot engine and exhaust
components, drive pump and impeller and engine induction when engine is running.
Page 9/134