OPERATION
1. Adjust the Bowl Height using the Bowl Adjustment Tube Lock
as required
2. Lock the Drain Tube firmly in place
3. Move the Waste Oil Drain under the drain plug , such that the
center of the bowl is almost exactly under the drain plug
4. Open the drain plug , allowing waste oil to drain under gravity
& get collected into the bowl
5. Bowl is connected to the Tank through the drain tube & waste
oil will start flowing into the tank
6.
Waste Oil Level is indicated from the Discharge Hose
which doubles as a Level Indicator
7. Tank can be used for collection up to approx. 55 litres (14.5
gallons). At this point , oil level in the discharge hose will reach
the highest point almost close to the top hose clamp
8.
To drain waste oil, loosen the Bowl Adjustment Tube lock &
remove the Drain Tube. It is very important to always raise
drain tube and close tank closure valve before emptying
9. Now Lock the Tank using the Tank Closure Valve
10. Insert the steel discharge spout at the end of the Hose into the
container in which waste oil is to be emptied
11. Take compressed air & connect it to the pressure regulator
fitted onto the tank. This is a tamper proof regulator set at
around 10-15 PSI (0.7-1 BAR). Note that pressure regulator
is fitted with a Safety Valve which will release air pressure in
case air pressure exceeds 20 PSI (1.4 BAR), thus acting as a
safety valve preventing possible damage to the tank
SPECIFICATIONS
WOD-68
Tank Capacity
68 Litres (18 Gallons)
Max. Collection Capacity
55 Litres (14.5 Gallons)
Bowl Capacity
10 Litres (10.5 Quarts)
Bowl Inner Diameter
14” ( 355 mm)
Length of Discharge Hose
2 metre
Maximum Adjustment Height
72” ( 1740 mm)
Minimum Height
34” (1135 mm)
Recommended Air Pressure
8 PSI (0.5 BAR)
Max. Air Pressure
150 PSI ( 10 BAR)
12. Within seconds , waste oil will flow out through the
discharge hose & empty the tank
13. Once waste oil is fully dispensed , disconnect the air
supply
14. Bottom of the Tank has a Drain plug which may
occasionally be opened to remove any sediments
collected at the bottom of the tank
