Generac Power Systems Magnum MGG100M, Руководство оператора

Страница: 10 / 84

Safety
2 MGG100M Operating Manual 36833 C
5. Engine misfires or there is excessive engine/generator vibration.
6. Protective covers are loose or missing.
7. If the ambient air temperature is above 120°F (49°C).
• Make sure slings, chains, hooks, ramps, jacks, and other types of lifting devices are attached securely
and have enough weight-bearing capacity to lift or hold the equipment safely. Always remain aware
of the position of other people around you when lifting the equipment.
• NEVER operate a unit while tired, distracted, or under the influence of drugs or alcohol.
ENGINE SAFETY
Internal combustion engines present special hazards during operation and fueling. Failure to follow the
safety guidelines described below could result in severe injury or death. Read and follow all safety warnings
described in the engine operator's manual. A copy of this manual was supplied with the unit when it was
shipped from the factory.
• DO NOT run engine indoors or in an area with poor ventilation. Engine exhaust contains carbon
monoxide, a deadly, odorless and colorless gas which, if inhaled, can cause nausea, fainting, or death.
Only use this unit outside and away from windows, doors, and ventilation equipment.
• DO NOT smoke around generator. Ensure that no combustible materials are left on or near generator,
as FIRE or EXPLOSION may result.
• DO NOT touch or lean against hot exhaust pipes or engine block.
• DO NOT clean air filter with gasoline or other types of low flash point solvents.
• DO NOT remove engine coolant cap while engine is hot.
• DO NOT operate the unit without a functional exhaust system.
• Prolonged exposure to sound levels in excess of 85 dB(A) can cause permanent hearing loss. Wear
hearing protection when working around a running engine.
• Keep hands, feet and loose clothing away from moving parts on the generator and engine.
• Keep area around exhaust pipes and air ducts free of debris to reduce the chance of an accidental fire.
• Batteries contain sulfuric acid which can cause severe injury or death. Sulfuric acid can cause eye
damage, burn flesh or eat holes in clothing. Protective eye wear and clothing are necessary when
working on or around the battery. Always disconnect the negative (-) battery cable from the corre-
sponding terminal before performing any service on the engine or other components.
ELECTRICAL SAFETY
The unit is powered by a generator driven by a gaseous engine. While the engine is running, potentially
lethal voltages are present at the 120V Ground Fault Circuit Interrupt (GFCI) receptacle located on the
side of the disconnect switch box and at the connection lugs and optional cam lock receptacles. Failure
to follow the safety guidelines described below could result in severe injury or death.
• Only a qualified and licensed electrician should make connections to the generator.
• NEVER wash the unit with high pressure hoses or power washers.
• NEVER start the unit under load. The circuit breakers must be OFF when starting the unit in MANUAL
mode. The circuit breakers can be ON only when started in AUTO mode. A transfer switch must be
used in AUTO mode to deflect the load upon start up.
• ALWAYS disconnect the negative (-) battery cable from the corresponding terminal before performing
any service on the engine, generator, or any other components. Remove the negative (-) battery cable
from the corresponding terminal if the unit is to be stored or transported.
• ALWAYS use extreme caution when servicing this unit in damp conditions. Do not service the unit if
your skin or clothing is wet. Do not allow water to collect around the base of the unit.
• ALWAYS ground the unit before use. Follow the National Electrical Code (NEC), state, and local
regulations.