This manual describes the installation and operation of the Model CDW1000L02 non-catalytic wood heater.
This heater meets US Environmental Protection Agency’s emission limits for wood heaters. Under specific
conditions this heater has been shown to deliver heat at rates ranging from 10,467 to 26,100 BTU per hour.
6” Flue Required
Figure A: Clearance from combustible constructions
Model No. CDW1000L02
This unit has been listed by Warnock
Hersey Limited to meet or exceed
ULC S-627 Canada and UL 1482 U.S.
Part No 90000139 Rev 02
NOTE: Retain this sheet for future reference
A minimum clearance of 18” (457mm) to the chimney connector
may be required by the authority having jurisdiction.
MADE IN CANADA BY CFM Corporation, 410 Admiral Boulevard, Mississauga, ON L5T 2N6 800-668-5323 www.cfmcorp.com
Unit must be placed on a noncombustible floor protection equivalent to 3/8” millboard.
Floor protector must have min. R value of .446
Consult your local building authorities for further information.
Contact your local building inspector
prior to installation.
A permit maybe required in your area.
HANDLE
Twist spring handle
in counter
clockwise motion while pushing on to handle;
spring handle will “thread” down to desired
location.
SPRING
CAUTION: BRICK FOR ASH DRAWER
MUST BE INSTALLED BEFORE
OPERATION OF WOOD HEATER
OPTIONAL FAN
An optional heat exchange blower is available for
this wood burning appliance. To order please see
the local dealer where you purchased your appliance.
CAUTION:
Do not open fire-door to a point where it
would be in contact with the combustible sidewall.
Figure “A”
*16”(406mm) U.S.A.
**18”(457mm) Canada
Inlet Air Control Settings
Desired Burn Setting Inlet Air Setting **Approx. BTU Output
Low Closed Fully 10,467
Med / Low ¼ Open 12,118
Med / High ¾ Open 19,413
High Fully Open 26,100
**Performance may vary depending on actual home operating conditions
2 FULL BRICKS
BAFFLE ASSEMBLY
BE SURE TO INSTALL TWO
FULL BRICKS (S16040) IN
BAFFLE AS SHOWN
10
9
1
2
3
4
5
7
8
Brick Pattern
Disposition Des Briques
Diseño de colocación de los ladrillos
14
14
14
14
14
14
14
15
15
15
15
16
16
17
18
WITH SINGLE WALL CONNECTOR
WITH DOUBLE WALL CONNECTOR
12”
(305)
8-1/2”
(216)
12-1/2”
(318)
8”
(203)
7”
(178)
5-1/2”
(140)
19-1/2”
(495)
15-1/2”
(394)
15”
(381)
10”
(254)
15”
(381)
13”
(330)
56”
(1422)
56”
(1422)
A
B
C
D
E
F
G
CLEARANCE TO COMBUSTIBLES
DECORATIVE NICKEL TRIM
Be sure to remove the protective plastic
coating after installing your wood heater
6
11
12
6
13
DESCRIPTION
PARTS LIST
1
DOOR - NO GLASS
2&3
GLASS AND GASKET
3
1/8” GLASS GASKET
4
SPRING HANDLE
5
AIR CONTROL SPRING HANDLE
6
5/8” DOOR GASKET
7
GLASS CLIP
SCREW
10
PUSH NUT
14
FIREBRICK LT 9”x4-7/16”x1-1/4”
15
FIREBRICK LT 7-1/4”x4-7/16”x1-1/4”
16
FIREBRICK LT - ANGLED
17
18
ITEM NO.
QTY
DESCRIPTION
NO.
LISTE DES PIÉCES
PORTE MONTÉE
PORTE - SANS LA VITRE
VITRE DE JOINT D’ÉTANCHEITÉ
JOINT DE LA VITRE 1/8po
POIGNÉE À RESSORT
POIGNÉE POUR L’ADMISSION D’AIR
JOINT DE LA PORTE 5/8po
FERRURE POUR LA VITRE
VIS
ÉCROU À RESSORT
BRIQUE 9”x4-7/16”x1-1/4”
BRIQUE 7-1/4”x4-7/16”x1-1/4”
BRIQUE - COUPLÉE EN ANGLE
LEYENDA NO.
DESCRIPCIÓN
NO.de PC
LISTA DE PIEZAS
1
1
4.0’
VIDRIO Y EMPAQUETADURA
S31117
4.5’
EMPAQUETADURA DE 1/8” PARA EL VIDRO
S15001
1
MANGO CON RESORTE
S11007
3
MANGO CON RESORTE PARA EL REGULADOR DEL AIRE
S11008
1
EMPAQUETADURA DE 5/8” PARA LA PUERTA
S15011
6
PRESILLA PARA EL VIDRIO
S37018
TORNILLO
S11086
2
2
UNIDAD DEL DEFLECTOR
S11090
11
LADRILLO REFRACTARIO LT 9”x4-7/16”x1-1/4”
S16214
4
LADRILLO REFRACTARIO LT 7-1/4”x4-7/16”x1-1/4”
S16048
1
LADRILLO REFRACTARIO - ANGULADO
S16043
2
S16040
S16042
1
QTÉE
CANT.
ART NO.
PART NO.
8
1
DOOR ASSEMBLY
HINGE PIN
9
FIREBRICK FOR ASH DRAWER
FIREBRICK LT - 4-1/2”x4-7/16”x1-1/4”
GOUPILLE DE CHARNIÈRE
BRIQUE POUR LE CENDRIER
BRIQUE 4-1/2”x4-7/16”x1-1/4”
UNIDAD DE PUERTA
UNIDAD DE PUERTA SIN VIDRIO
PASADOR DE BISAGRA
LADRILLO REFRACTARIO LT 4-1/2”x4-7/16”x1-1/4”
LADRILLO REFRACTARIO DEPÓSITO DE CENIZAS
90000135
1
90000136
90000129
13
11
12
NICKEL ASH FENDER TRIM
1
90000065
1
90000066
NICKEL BODY TRIM
GARANTURE DU BOÎTIER EN NICKEL
MOLDURA DE NÍQUEL PARA EL CUERPO DEL CALAFACTOR
MOLDURA DE NÍQUEL DEL PROTECTOR CONTRA LA CENIZA
GARANTURE DU GARDE-FEU EN NICKEL
ASH DRAWER ASSEMBLY
L’ASSEMBLEE DE TROIR DE CENDRE
ASAMBLEA DE CAJON DE CENIZA
1
S31325
Dutchwest
3FT(1M) MIN
FROM ROOF
PENETRATION
MINIMUM OVERALL
HEIGHT FROM FLOOR
15FT(5M)
2ft(635mm) HIGHER THAN
NEAREST POINT OF
ROOF WITHIN 10ft(3M)
G
BACK WALL
S
ID
E
W
A
L
L
BACK WALL
S
ID
E
W
A
L
L
B
E
*16
**18”
A
D
8”
8”
C
F
C
F
8”
