8
SHUTDOWN INSTRUCTIONS
1.
Make sure the gun is closed, reduce the engine speed to half rev's and turn the engine
switch to OFF and turn the fuel valve to OFF.
2.
Pull the gun trigger to release any built up pressure (make sure you do not spray
people or objects.) Turn off the water supply and remove the water supply hose from
the pump.
3.
Disconnect the pressure hose from the pump and gun and store on the hooks provided
on the trolley.
4.
For safety and your liability protection, remove high pressure hose and store gun/wand
in a secure place with this manual to eliminate possibility of unauthorized and
untrained personnel from operating the machine.
CHECK & MAINTENANCE
Daily Checks
Regular inspection of your pressure cleaner is the key to prolonging its life. Follow these
simple daily checks. This must be done with the engine OFF.
1.
Check air filter for dirt and clean or replace as required. Refer to engine owner manual.
2.
Check engine oil level. (Dipstick is attached to inside of oil cap.) Refer engine owner
manual.
3.
Check engine fuel level.
4.
Check high pressure hose for kinks, twists or damage. Replace any damaged hose.
5.
Check that the pump oil level is within operation range on the pump dipstick (model
CPV2700X21) Model CPV2700X17 has a sealed oil filled gearbox and must be refilled by
service dealer.
6.
Check that the water supply is adequate for your machine.
7. Check water inlet filter (situated behind the water inlet connector) remove with long
nose pliers and clean when as necessary.
Preventative Maintenance
Change pump oil after first 50 hours of use or first season, then every 300 hours or as
needed. Please use SAE30 Universal Pump Oil and follow the below steps:
1.
Un-thread the oil cap on the top of the pump; model CPV2700X21 ONLY.
2.
Put a container under the pump then unscrew the drain plug on the bottom of the
pump;
3.
After oil drains away completely, screw the drain plug into the drain hole again, make
sure the o-ring is with the plug.
4.
Refill pump oil via the top hole of the pump until the oil level is to the top of the oil
dipstick level indicator.
5.
Screw on the oil cap.
N.B. Dispose of used oils as per your local environmental disposal by laws.
