CORRECT CRAFT Sport Nautique 216, Руководство пользователя

Страница: 44 / 84

3.2
dealer adjust the stuffing box. There is a detailed instruction for this in the
boat care section.
• Check to make sure there are no ropes, gear bags, arms/legs near the belts
and pulleys of the engine. Severe injury can result by becoming entangled in
the belts of the engine while it is running. Make sure the boat is deep enough
in the water to supply the water intake with water to cool the engine. Move
the throttle into the neutral position. This is in the “straight up” position.
WARNING: Before you start your engine, always ventilate the engine
compartment by running the blower for four (4) minutes to remove any
fuel fumes that may be in the bilge. This is especially important after
repairing or refueling to check for fuel spills or leaks before starting the
engine.
• Close the engine box before starting engine.
• Start the engine.
CAUTION: Do not continue to operate the starter for more than 30
seconds without pausing to allow the starter motor to cool off for five (5)
minutes.
This allows the battery to recover between starting attempts.
WARNING: In order to prevent personal injury to you or others, whenever
the engine is running the engine box must be closed. Never operate the
engine with the engine box open or while someone is in the area of an open
engine box. Never open the engine box unless the engine is turned off and
rotating parts are stationary and remain in a stationary position. Rotating
machinery can cause injury and even death if an accident should occur. IT
IS RECOMMENDED THAT ALL WORK ON THE ENGINE BE DONE
BY TRAINED AND QUALIFIED SERVICE PERSONNEL.
During the warm up period, scan the gauges for correct operation of all
the systems:
• Oil pressure 35- 80 PSI (Approx..) at 2000 RPM
• Cooling water flow and water temperature 140 -170 degrees
• Cooling water temperature for fresh water systems: 170 - 210 Degrees
• Volts should rise to around 13 - 14 volts or higher
• Idle RPM (600 - 700) in gear
CAUTION: Do not operate at high RPM’s in neutral. Do not shift into
forward or reverse at engine speeds above idle RPM’s.
CAUTION: Do not operate engine without cooling water flowing through
the water pump or the neoprene water pump impeller will become
damaged, and severe engine damage may result.
If the fuel injected engine does not start:
• If the fuel filter has just been changed or if the fuel system has been run dry,
Sport Nautique 216 2003.qxd 7/29/02 11:23 AM Page 3.2