Club Car Pioneer 900, Руководство по техническому обслуживанию

Страница: 140 / 344

TROUBLESHOOTING AND ELECTRICAL SYSTEM Test Procedures
Page 11-32 2001 Pioneer 900 Gasoline Vehicle Maintenance and Service Manual
11
2. Check that the wires are connected correctly and are tight. If they are not, rewire or tighten as necessary.
3. Check the engine RPM setting to ensure that it is adjusted correctly. See Engine RPM Adjustment,
Section 14, Page 14-13.
4. With the battery in good condition and fully charged, run the engine for several minutes to bring the
voltage regulator to operating temperature.
5. Turn the key switch to the OFF position, killing the engine. Using a multimeter set to 20 volts DC, place
the red (+) probe on the large post of the solenoid with the red wire from the voltage regulator attached.
Place the black (–) probe on the negative (–) battery post (Figure 11-37, Page 11-32). With the For-
ward/Reverse handle in the NEUTRAL position and the wheels chocked, turn the key switch to the
START position to start the engine. Depress the accelerator to run the engine at full governed speed. If
the reading is between 14.7 and 15.3 volts, the regulator is good. If the reading is lower than 14.7 volts
but rising steadily, check battery condition. See Hydrometer Test on page 11-21. If the reading is
lower than 14.7 volts and not rising, and the starter/generator is good; or if the reading is over 15.3
volts and continues to rise, replace voltage regulator. See Voltage Regulator Removal, Section 12,
Page 12-13.
TEST PROCEDURE 13 – DISCONNECTED KILL WIRE
Read DANGER and WARNING on page 11-1.
NOTE: Keep the battery connected while performing this test procedure.
1. Place the Forward/Reverse handle in the NEUTRAL position, and chock the wheels.
2. Disconnect the engine-kill white/black wire at the bullet connector located next to the RPM limiter (Fig-
ure 11-39, Page 11-33).
Figure 11-37 Test Voltage Regulator
BATTERY
VOLTAGE
REGULATOR
SOLENOID
RE
D
2m
20
m
200
m
2k
200
200
200 200
20
2
200
m
500
20k
200k
2000
k
Ω
Ω
1000
OFF
WAVETEK 5XL
V
V
V
A
! !
COM 200nA
MAX
1000 ---
750V
FUSED