Club Car Pioneer 1200, Руководство по техническому обслуживанию

Страница: 102 / 360

WHEELS AND TIRES Wheels
Page 8-2 2001 Pioneer 1200 Gasoline Vehicle Maintenance and Service Manual
8
WHEELS
Read WARNING on page 8-1.
WHEEL REMOVAL
1. Slightly loosen the lug nuts on the wheel to be removed.
2. Raise the end of the vehicle from which the wheel is to be removed. Make sure the wheels are off the
ground. See WARNING on page 8-1.
3. Remove the lug nuts and remove the wheel.
WHEEL INSTALLATION
1. Install wheel(s) and tighten the lug nuts (using a crisscross pattern) until they are snug. See following
NOTE.
NOTE: Traks Max II tires are directional. For optimum performance on muddy terrain, install all four tires as
shown (Figure 8-1, Page 8-2).
2. Lower the vehicle and finish tightening the lug nuts (using a crisscross pattern) to 55 ft-lb (74.6 N·m).
3. Inspect the brake hoses at the front wheels. When turning the steering wheel all the way from left to
right and back again, the hoses should not come in contact with any component, especially the wheels
or tires.
4. Check the park brake cables. The cables should not come in contact with either of the rear wheels or
tires.
Figure 8-1 Tire Rotation
TRAKS MAX II
TREAD
DIRECTION
OF FORWARD
ROTATION