Club Car IQ PLUS 2008, Дополнение к руководству по обслуживанию и ремонту

Страница: 29 / 164

ELECTRICAL SYSTEM AND TESTING Troubleshooting
2008-2011 IQ Plus Electric Vehicle Maintenance and Service Supplement Page 11-15
11
TEST PROCEDURE 1 – BATTERIES / VOLTAGE CHECK
See General Warning, Section 10, Page 10-1.
NOTE: The batteries must be properly maintained and fully charged in order to perform the following test
procedures. Battery maintenance procedures, including watering information and allowable min-
eral content, can be found in Section 14 of this manual.
See Battery Care, Section 14, Page 14-4.
The battery voltage can be displayed with the IQDM handset (CC P/N 102241804). If an IQDM handset is not
available, proceed to Batteries / Voltage Check without the IQDM Handset on page 11-15.
Batteries / Voltage Check with the IQDM Handset
1. Connect the IQDM to the vehicle. See Plugging the Handset into the Vehicle, Section 12, Page 12-1.
2. Access the Test menu and select BATT VOLTAGE by using the SCROLL DISPLAY buttons. The IQDM
should indicate at least 48 volts with the batteries fully charged. If not, check for loose battery connec-
tions or a battery installed in reverse polarity. Refer to
Section 14 – Batteries , for further details on bat-
tery testing.
Batteries / Voltage Check without the IQDM Handset
1. With batteries connected and using a multimeter set to 200 volts DC, place red (+) probe on the positive
(+) post of battery no. 1 and the black (–) probe on the negative (–) post of battery no. 8 (Figure 11-7,
Page 11-15) . The multimeter should indicate at least 48 volts with the batteries fully charged. If not,
check for loose battery connections or a battery installed in reverse polarity. Refer to Section 14 –
Batteries, for further details on battery testing.
Figure 11-7 IQ Plus Battery Configurations
1
2
3
4
6
5
FRONT
OF VEHICLE
7
8
FRONT
OF VEHICLE
1
3
5
7
8
2
6
TRANSPORTER 4 AND 6
CARRYALL 2
CARRYALL 6 (STYLE B)
VILLAGER 6 AND 8
FRONT
OF VEHICLE
1
3
5
8
2
4
6
7
battery cables.
CARRYALL 6 (STYLE A)
(-)
(+)
(+)
(-)
(+)
(-)
TURF 2
4