21
Fuel Tank
GASOLINE VEHICLE - FUEL SYSTEM
DANGER
• Ensure line is connected properly to avoid a leak that can cause a fire.
7.
Connect the wire harness to the fuel pump module plug (3).
8.
Install the fuel tank retaining strap (2).
9.
Install the screws (1). Tighten the screws to 31 in·lb (3.5 N·m).
10.
Clean spilled fuel. Remove any drained fuel from the area.
11.
Connect the battery.
12.
Disable the vehicle.
13.
Set the Maintenance/Operate switch to MAINTENANCE.
14.
Turn the key switch to ON and check for fuel leaks. Repeat as necessary to build fuel pressure. Any leaks
found must be fixed.
DANGER
• Repair all fuel leaks before returning the vehicle to service.
15.
If no leaks are found, set the Maintenance/Operate switch to OPERATE.
FUEL TANK
GENERAL INFORMATION
The vehicle is equipped with a high impact, plastic fuel tank.
WARNING
• If the fuel tank is damaged, replace it. Do not attempt to repair it. See the following tank removal
and disposal procedure.
CAUTION
• Add only unleaded fuel to the tank. Do not put oil in the fuel tank.
NOTE:
This gasoline vehicle complies with the California Air Resources Board (CARB) and EPA evaporative
emissions regulations when equipped with SAEJ30R9 1/4 in (6.3 mm) fuel vent hose and 3/16 in (4.78 mm)
fuel vent hose. To remain in compliance with California and EPA regulations, replace any fuel vent hose on
this vehicle with Club Car fuel vent hoses or equivalent.
FUEL TANK REMOVAL
1.
Disable the vehicle.
2.
Set the Maintenance/Operate switch to MAINTENANCE.
3.
Disconnect the battery.
4.
Clean the top of the fuel tank and fuel pump module.
Page 21-20
2020 Precedent,Villager 2 and 4 Maintenance and Service Manual
Содержание DS Villager 4
