Club Car Carryall XRT 1550, Руководство по техническому обслуживанию и ремонту

Страница: 327 / 432

DIESEL ENGINE, MUFFLER, FUEL SYSTEM, AND
CLUTCHES Fuel System
16
13. Remove the passenger-side bed latch bracket from the frame.
14. Remove the fuel tank.
Fuel Tank Storage or Disposal
1. Remove the cap from the tank and thoroughly rinse it with water. The cap may be discarded or kept as a spare.
2. Use a well-ventilated area and flush the fuel tank with water to remove any remaining fuel.
3. Set the tank upside down in a well-ventilated area so that the water can drain. Allow the tank to sit for 24
hours to dry.
See following WARNING.
WARNING
• Dispose of wastewater and fuel tank in accordance with federal, state, and local laws and ordinances.
4. Store the tank upside down with the cap installed in a well-ventilated area.
Fuel Tank Installation
1. Place the fuel tank in the vehicle.
2. Insert the tab end of the strap into the frame bracket and place the strap in the indentions on the tank.
3. Feed the threaded tab end down into the bottom of the frame. Install a nylon locknut and tighten the nut to
40 in-lb (4.5 N·m).
4. Connect the clear vent tube to the fuel tank vent and secure the tube with a new clamp.
5. Connect the fuel line to the primary fuel filter on the vehicle frame and secure it with a new clamp.
6. Connect the fuel return line to the engine and secure it with a new clamp.
7. Connect the black wire and orange wire to the sensor (Figure 16-14, Page 16-17) .
2157
Figure 16-14 Fuel Level Sensor
8. Slide the rubber boot over the stud.
9. Install the passenger-side bed latch bracket on the frame with a bolt and flanged nylon locknut. Tighten the
hardware to 20 ft-lb (27 N·m).
10. Install the seat frame. Tighten the nut to 37 ft-lb (50 N·m). See Seat Support Installation, Section 4, Page 4-10.
11. Install the top portion of the ROPS (Roll Over Protective Structure). See ROPS Installation, Section 4, Page 4-8.
12. Install the center seat plate.
13. Add the appropriate fuel to the fuel tank.
14. Connect battery. See Connecting the Battery – Gasoline/Diesel Vehicles, Section 1, Page 1-4.
15. Install both seats.
2013 Carryall 295/XRT 1550 Maintenance and Service Manual Page 16-17