Club Car CARRYALL 272, Руководство по техническому обслуживанию и ремонту

Страница: 237 / 312

FUEL SYSTEM Choke and Air Intake System
2006-2010 Turf/Carryall 272/472 and XRT 1200/1200 SE Maintenance and Service Manual Page 14-13
14
2.2. Place hose (16) onto air box top (4) and secure with wire clamp (15).
2.3. Attach choke cable (18) to the air box top (4).
See Choke Cable Installation on page 14-12.
3. Carryall 472/XRT 1200 SE:
3.1. Place air box assembly into vehicle and install three flat washers (24) and screws (25) from under-
side of air box mounting plate into air box (12) (Figure 14-11, Page 14-16) . Tighten to 33 in-lb (3.7
N·m).
3.2. Place hose (16) onto air box top (4) and secure with wire clamp (15).
3.3. Attach choke cable (18) to the air box top (4)
See Choke Cable Installation on page 14-12.
4. Test choke for proper operation.
INTAKE DUCT REPAIR
If the intake duct is badly torn or has large holes, it will need to be replaced.
INTAKE DUCT REMOVAL
NOTE: This procedure is best accomplished using two people.
1. Turn the key switch OFF and remove the key. Place the Forward/Reverse handle in the NEUTRAL posi-
tion. Chock the wheels.
2. Turf 272/Carryall 272/XRT 1200:
2.1. Remove the front body. See Front Body Removal, Section 4, Page 4-5.
2.2. Slightly loosen the lug nuts on the both front wheels.
2.3. Raise the front of the vehicle with a floor jack.
2.4. Place jack stands under the vehicle outer front frame I-beam and lower onto jack stands.
See Figure 5-2, Section 5, Page 5-3. See WARNING “Lift only one end...” in General Warning,
Section 1, Page 1-1 .
2.5. Remove the front wheels.
2.6. Remove the bolt (1) that connects the steering joint to the steering column shaft
(Figure 14-9,
Page 14-13) . See following NOTE.
Figure 14-9 Compound Steering Joint
1
2