Club Car CARRYALL 272, Руководство по техническому обслуживанию и ремонту

Страница: 151 / 312

TROUBLESHOOTING AND ELECTRICAL SYSTEM: FE400, KEY-START ENGINE Test Procedures
2006-2010 Turf/Carryall 272/472 and XRT 1200/1200 SE Maintenance and Service Manual Page 11-23
11
TEST PROCEDURE 13 – GROUNDED KILL WIRE
See General Warning, Section 1, Page 1-1.
NOTE: Keep the battery connected while performing this test procedure.
1. Turn the key switch OFF and remove the key. Place the Forward/Reverse handle in the NEUTRAL posi-
tion. Chock the wheels.
2. Disconnect the engine-kill white/black wire at the bullet connector located next to the RPM limiter
(Figure 11-24, Page 11-24) .
NOTE: Disconnecting the engine-kill wire removes it from the start/stop circuit.
3. Turn the key switch to the START position and release after the engine starts. If the engine starts and
continues to idle, check the kill-wire for grounding, the kill limit switch, and the key switch. See Test Pro-
cedure 18 – Engine Kill Wire on page 11-31. See following WARNING.
ý
WARNING
• When the white/black engine kill wire is disconnected, the engine will not stop running after
the key switch is turned to the OFF position. It will be necessary to pull and hold the choke
handle until the engine stops running.
4. If the engine does not run, connect the white/black wire at the bullet connector next to the RPM limiter
and proceed to Test Procedure 14 – Ignition Spark on page 11-23.
TEST PROCEDURE 14 – IGNITION SPARK
See General Warning, Section 1, Page 1-1.
NOTE: Keep the battery connected while performing this test procedure.
1. Turn the key switch OFF and remove the key. Place the Forward/Reverse handle in the NEUTRAL posi-
tion. Chock the wheels.
2. Remove the plug wire from the spark plug. Using an ignition spark gap test tool (Thexton 404
®
or equiv-
alent), check for correct spark (Figure 11-23, Page 11-24) .
Figure 11-22 Test Voltage Regulator
BATTERY
VOLTAGE
REGULATOR
SOLENOID
RE
D
2m
20
m
200
m
2k
200
200
200 200
20
2
200
m
500
20k
200k
2000
k
1000
OFF
WAVETEK 5XL
V
V
V
A
! !
COM
200nA
MAX
1000 ---
750V
FUSED