WHEEL BRAKE ASSEMBLIES
Brake Shoe Installation (Manually-Adjusted Brakes)
6
BRAKE SHOE INSTALLATION (MANUALLY-ADJUSTED BRAKES)
See General Warning on page 1-1. See also WARNING on page 6-1.
NOTE:
Components of the front wheel brake assembly are identical to the rear wheel manually-adjusted brake
assembly. The front brake assembly is rotated 90° (when compared to the rear brake assembly) so the
adjusting bolt on each assembly is oriented to the rear of the vehicle rather than at the top of the assembly
1.
Position one shoe in the slots in the mounting block anchor piston and brake actuator
See following WARNING.
WARNING
• When installing brake shoes, the shoes must be oriented with tips stamped J10 inserted into the
mounting block anchor piston slots rather than into the brake actuator slots (Figure 6-9, Page 6-5).
Incorrectly installed brake shoes will be too tight and make adjustment of the brake impossible.
00
J10
1
2
Figure 6-9
Orient and Insert Shoes
Figure 6-10
Retainer Clip
2.
Install shoe retainer clip (1), using pliers to compress clip while turning clip retainer pin (2) into position
3.
Attach the springs (with hooks pointing outwards) onto the shoe already installed. Then hold the other shoe next
to it, correctly oriented, and attach the springs to it
See following NOTE.
NOTE:
With brake shoe tips marked J10 oriented to the mounting block, the stamping will be visible on one shoe only.
The other J10 stamping will be facing the backing plate and will not be visible.
4.
While maintaining spring attachment on both shoes, position the tips of the second shoe into mounting slots and
then push shoe into place. Hold shoe in position and install the retaining clip and pin
.
5.
After the shoes are installed, move them together up and down and side to side to make sure that they will easily
slide approximately 1/4 to 3/8 inch (6.3 to 9.5 mm) without binding. Make sure the shoes are positioned vertically
2007-2009 Turf 252, Carryall 252 and XRT 900 Maintenance and Service Manual
Page 6-5
Содержание CARRYALL 252 2007
