463421908 • 7
Safety Tips
s
Before opening LP tank valve, check the coupling nut for
tightness.
s
When grill is not in use, turn off all control knobs and LP tank
valve.
s
Never move grill while in operation or still hot.
s
Use long-handled barbecue utensils and oven mitts to avoid
burns and splatters.
s
Maximum load for sideburner and side shelf is 10 lbs.
s
The grease cup
must
be inserted into grease clip and
emptied after each use. Do not remove grease cup until grill
has completely cooled.
s
Clean grill often, preferably after each cookout. If a bristle
brush is used to clean any of the grill cooking surfaces,
ensure no loose bristles remain on cooking surfaces prior to
grilling. It is not recommended to clean cooking surfaces
while grill is hot.
s
If you notice grease or other hot material dripping from grill
onto valve, hose or regulator, turn off gas supply at once.
Determine the cause, correct it, then clean and inspect valve,
hose and regulator before continuing. Perform a leak test.
s
The regulator may make a humming or whistling noise during
operation. This will not affect safety or use of grill.
s
Only use the pressure regulator and hose assembly supplied
with this grill. Replacement pressure regulator and hose
assemblies must be specified or supplied by Char-Broil, LLC.
s
If you have a grill problem see the
"Troubleshooting Section"
.
s
If the regulator frosts, turn off grill and LP tank valve
immediately. This indicates a problem with the tank and it
should not be used on any product. Return to supplier!
CAUTION
• Putting out grease fires by closing the lid is not
possible. Grills are well ventilated for safety
reasons.
• Do not use water on a grease fire. Personal injury
may result. If a grease fire develops, turn knobs
and LP tank off.
• Do not leave grill unattended while preheating or
burning off food residue on HIGH. If grill has not
been regularly cleaned, a grease fire can occur
that may damage the product.
Ignitor Lighting
s
Do not lean over grill while lighting.
1.
Turn
OFF
all burner control valves.
2.
Turn on gas sorce or tank.
3.
Open lid during lighting
.
4.
To ignite, turn IGNITION BURNER knob to HIGH.
5.
Push and hold ELECTRONIC IGNITOR button.
6.
If ignition does NOT occur in 5 seconds, turn the burner
controls off, wait 5 minutes and repeat the lighting procedure.
7.
Ignite other burners by turning knob to .
Lighting instructions continued on next page.
WARNING
For Safe Use of Your Grill and to Avoid Serious
Injury:
•
Do not let children operate or play near grill.
•
Keep grill area clear and free from materials that burn.
•
Do not block holes in sides or back of grill.
•
Check burner flames regularly.
•
Use grill only in well-ventilated space. NEVER use in
enclosed space such as carport, garage, porch,
covered patio, or under an overhead structure of any
kind.
•
Do not use charcoal or ceramic briquets in a gas grill.
(
Unless
briquets are supplied with your grill.)
• Use grill at least 3 ft. from any wall or surface.
Maintain 10 ft. clearance to objects that can catch fire
or sources of ignition such as pilot lights on water
heaters, live electrical appliances, etc.
• Keep ventilation opening(s) of the tank enclosure free
and clear from debris.
• Apartment Dwellers:
Check with management to learn the requirements
and fire codes for using an LP gas grill in your
apartment complex. If allowed, use outside on the
ground floor with a three (3) foot clearance from walls
or rails. Do not use on or under balconies.
• NEVER attempt to light burner with lid closed. A
buildup of non-ignited gas inside a closed grill is
hazardous.
• Never operate grill with LP tank out of correct
position specified in assembly instructions.
• Always close LP tank valve and remove coupling
nut before moving LP tank from specified
operation position.
