Disconnect all power before installing or
servicing the heater. Failure to do so could result
in personal injury and/or property damage. All
maintenance and installation should be done by
qualified personnel in compliance with local
codes and rules of the jurisdiction of installation.
15.0
As a safety precaution and to avoid non-scheduled
downtimes, replace the heating element if a pronounced hot spot
(area of the element that glows brighter) is visible along its heated
section.
16.0
To disconnect heater, turn controls to “OFF” and turn off
power to heater circuit at main disconnect panel.
After performing maintenance, and prior to
energization, an insulation resistance check
must be performed. Heater with values less
than 1 M should follow a drying process. Please
contact factory for details on procedure if heater
is under 1 MΩ.
Prior to operation, an insulation resistance
check must be performed. Heater with values
less than 1 MΩ should follow a drying process.
Please contact factory for details on procedure if
heater is under 1 MΩ.
Use this heater only as described in this
manual. Any other use not recommended by the
manufacturer may cause fire, electric shock, or
injury to persons.
11.0
Heaters that have not been energized for a prolonged
period shall be restarted under close supervision for the first thirty
minutes of operation.
12.0
Energize the heater at the voltage shown on the nameplate
and visually check the element to ensure that it slides freely on
expansion.
13.0
Do not operate any heater after it malfunctions. Disconnect
power at service panel and have heater inspected by a qualified
electrician before reusing.
14.0
Do not use outdoors unless heater is designed and
manufactured for outdoor use.
ВНИМАНИЕ
ВНИМАНИЕ
ПРЕДУПРЕЖДЕНИЕ
OPERATION
MAINTENANCE
MI182 REV.10.00 Page 2 of 2
CCI Thermal Technologies Inc. 1 Hunter Valley Road, Orillia, ON L3V 0Y7 Tel. (705) 325-3473 Fax (705) 325-2106
www.ccithermal.com
ВНИМАНИЕ
ВНИМАНИЕ
ПРЕДУПРЕЖДЕНИЕ
ВНИМАНИЕ
ВНИМАНИЕ
ПРЕДУПРЕЖДЕНИЕ
WARRANTY
CCI Thermal Technologies Inc. warrants to the purchaser of each new product that any part thereof which proves to be defective in
material or workmanship under normal use within 18 months of the date of shipment or 12 months from the date of start of operation
(whichever occurs first) will be repaired or replaced without charge. Any such defect should be brought to the attention of the company’s
office from which the product was purchased, which is authorized to furnish or replacement within the terms of this warranty.
The Company will not be responsible for any expenses incurred in installation, removal from service, transportation cost, or damages
of any type whatsoever, including incidental or consequential damages. Some states or provinces do not allow exclusion or limitation of
incidental or consequential damages so the preceding exclusion or limitation may not be applicable to you.
Since we cannot anticipate or control the condition under which our products may be used, we accept no responsibility for the safety and
suitability of our products when used alone or in combination with other products. Tests for safety and suitability of the products should
be done by the user.
This warranty will not apply if, in the judgement of the Company damage or failure has resulted from accident, alteration, misuse, abuse or
operation on an incorrect power supply. The foregoing is in lieu of other warranties expressed or implied. CCI Thermal Technologies Inc.
neither assumes no authorizes any person to assume for it any other obligation, during transportation, installation and operation or liability
in connection with the said product.
Since the paint finish may be damaged in use, no warranty applies to such paint finish except for manufacturing defects which become
apparent within 30 days from date of installation.
Heaters are not guaranteed against damage caused by corrosion.
Radiant element longevity is largely dependent on the application which it is being used in, cycle times and usage. As such we do not
supply warranty on the element.
ВНИМАНИЕ
ВНИМАНИЕ
ПРЕДУПРЕЖДЕНИЕ
