Outdoor Charcoal Barbecue Grill
Model No. CBT1602C & CBT1602CR
2
W
DANGER: Failure to follow the dangers, warnings and cautions in this manual may result in serious bodily injury or death, or in a fire or an explosion
causing damage to property.
W
WARNINGS:
Important Safeguards
W
This grill is for outdoor use only, and should NOT be used in a building,
garage or any other enclosed area.
W
Do NOT operate, light or use this appliance within ten feet (3.05 m) of
walls, structures or buildings.
W
For residential use only. This grill is NOT for commercial use.
W
Never use charcoal that has been pre-treated with lighter fluid. Use only
a high grade plain charcoal, charcoal/wood mixture, lump charcoal or
cooking wood. The conversion to or attempted use of any other fuel
source in this charcoal grill is dangerous and will void your warranty.
W
This grill is NOT intended for and should never be used as a heater.
TOXIC fumes can accumulate and cause asphyxiation.
W
Do NOT use grill for indoor cooking. TOXIC carbon monoxide fumes can
accumulate and cause asphyxiation.
W
This grill is safety certified for use in the United States and/or Canada
only. Do NOT modify for use in any other location. Modification will
result in a safety hazard and will void your warranty.
W
Apartment dwellers: Check with management to learn the requirements
and fire codes for using a charcoal grill in your apartment complex.
If allowed, use outside on the ground floor with a ten foot (3.05 m)
clearance from any structure. Do NOT use on or under balconies.
W
Minimum clearance from sides and back of unit to combustible
construction is 36 inches (91.4 cm). Do NOT use this appliance under
any type of overhang or roof.
W
Do NOT use gasoline, kerosene or alcohol for lighting.
W
Do NOT use in an explosive atmosphere. Keep grill area clear and free
from combustible materials, gasoline and other flammable vapors and
liquids.
W
Do NOT store or use gasoline or other flammable liquids or vapors
within 25 feet (7.62 m) of this appliance.
W
Do NOT block holes in sides or back of grill.
W
Inspect grill before each use.
W
Do NOT alter grill in any manner. Any alteration will void your warranty.
W
Do NOT build this model of grill in any built-in or slide-in construction.
Ignoring this warning could cause a fire or an explosion that can
damage property and cause serious bodily injury or death.
W
Do NOT use the grill unless it is COMPLETELY assembled and all parts
are securely fastened and tightened.
W
This grill should be thoroughly cleaned and inspected on a regular
basis.
W
Use only Blue Rhino Global Sourcing, Inc. factory-authorized parts. The
use of any part that is not factory-authorized can be dangerous and will
void your warranty.
W
Do NOT operate this appliance without reading “Operating Instructions”
in this manual.
W
To avoid burns, do NOT touch metal parts of grill until they have
completely cooled, unless you are wearing protective gear (pot holders,
gloves, BBQ mittens, etc.).
W
Never touch grates (charcoal, cooking or warming), ashes or coals to
see if they are hot.
W
Do NOT use on wooden decks, wooden furniture or other combustible
surfaces.
W
This grill is NOT to be used in or on boats or recreational vehicles.
W
Position grill so wind cannot carry ashes to combustible surfaces.
W
Do NOT use in high winds.
W
Never lean over the grill when lighting.
W
Do NOT leave a lit grill unattended. Keep children and pets away from
grill at all times.
W
Do NOT attempt to move grill when in use. Allow the grill to cool before
moving or storing.
W
Do NOT leave grill unattended while preheating or burning off food
residue.
W
When cooking, fire extinguishing materials should be readily accessible.
In the event of an oil/grease fire, do NOT attempt to extinguish with
water. Use type BC dry chemical fire extinguisher or smother with dirt,
sand or baking soda.
W
Always open grill lid carefully and slowly as heat and steam trapped
within grill can severely burn you.
W
If grill has not been cleaned, a grease fire can occur that may damage
the product.
W
Do NOT place empty cooking vessels on the appliance while in
operation.
W
Use caution when placing anything on the grill while the appliance is in
operation.
W
Never add lighting fluid to hot or warm coals as a flashback may occur
causing serious injury or damage to property.
W
Always place your grill on a hard, non-combustible level surface. An
asphalt or blacktop surface may not be acceptable for this purpose.
W
Do NOT remove the ashes until they are completely and fully
extinguished.
W
Live hot briquettes and coals can create a fire hazard.
W
Always empty the bottom bowl and grill after each use.
W
Do NOT place fuel (charcoal briquettes, wood or lump charcoal) directly
into bottom of grill. Place fuel only on the charcoal pan/grid.
W
Do NOT allow charcoal to rest on the walls of grill. Doing so will greatly
reduce the life of the metal and finish of your grill.
W
Check to make sure the air vents are free of debris and ash before using
the grill.
W
Extinguished coals and ashes should be placed a safe distance from all
structures and combustible materials.
W
With a garden hose, completely wet the surface beneath and around
grill to extinguish any ashes, coals or embers that may have fallen
during the cooking or cleaning process.
W
The use of alcohol, prescription or non-prescription drugs may impair
the consumer’s ability to properly assemble and/or safely operate this
grill.
W
Always wear protective gloves when adding fuel (charcoal briquettes,
wood or lump charcoal) to retain desired heat level.
W
Keep all electrical cords away from a hot grill.
W
Always use a meat thermometer to ensure food is cooked to a safe
temperature.
W
Never cover entire cooking area with aluminum foil.
W
Use protective gloves when assembling this product.
W
Do NOT force parts together as this can result in personal injury or
damage to the product.
W
Do NOT touch ash receiver or ash receiver handle until grill has
completely cooled, unless you are wearing protective gear.
W
Do NOT touch air vent or air vent handle until grill has completely
cooled, unless you are wearing protective gear.
W
Death, serious injury or damage to property may occur if the above is
not followed exactly.
