7690785.01 (1-05/18)
42
I
N
S
T
A
L
L
E
R
S
e
c
t
i
o
n
(
e
n
)
18. ANNUAL SERVICING
7KHVHUYLFHPXVWEHSHUIRUPHGRQO\E\TXDOL¿HGDQGFRPSHWHQWVWDIILQDFFRUGDQFHZLWKWKH*DVVDIHW\,QVWDOODWLRQDQGXVH
UHJXODWLRQV,Q8.WKLVSHUVRQQHHGWREHDSSURYHGE\WKH+HDOWKDQG6DIHW\([HFXWLYH7RRSWLPLVHERLOHUHI¿FLHQF\FDUU\RXWWKH
following at the annual service:
• Check the appearance and airtightness of the gaskets of the gas and combustion circuits. Replace any worn seals with new
RULJLQDOVSDUHV
•
&KHFNWKHVWDWHDQGFRUUHFWSRVLWLRQRIWKHLJQLWLRQDQGÀDPHVHQVLQJHOHFWURGHV
•
&KHFNWKHVWDWHRIWKHEXUQHUDQGPDNHVXUHLWLV¿UPO\¿[HG
•
&KHFNIRUDQ\LPSXULWLHVLQVLGHWKHFRPEXVWLRQFKDPEHU8VHDYDFXXPFOHDQHUWRGRWKLV
•
&KHFNWKHJDVYDOYHLVFRUUHFWO\FDOLEUDWHG
•
&KHFNWKHSUHVVXUHRIWKHKHDWLQJV\VWHP
•
&KHFNWKHSUHVVXUHRIWKHH[SDQVLRQYHVVHOV\VWHP
•
&KHFNWKHIDQZRUNVFRUUHFWO\
•
0DNHVXUHWKHÀXHDQGDLUGXFWVDUHXQREVWUXFWHG
•
&KHFNIRUDQ\EORFNDJHVLQVLGHWKHVLSKRQ
• Check correct operation of the fumes pressure switch, where present. Blow into the positive connector of the pressure switch
without using electromechanical devices, until you hear the activation click.
%HIRUHFRPPHQFLQJDQ\PDLQWHQDQFHRSHUDWLRQVPDNHVXUHWKHERLOHULVGLVFRQQHFWHGIURPWKHSRZHUVXSSO\$IWHUVHUYLFLQJ
UHVHWWKHRULJLQDORSHUDWLQJSDUDPHWHUVRIWKHERLOHULIWKH\ZHUHFKDQJHG
18.1 CLEANING THE CONDESATE TRAP
Unscrew the lower section of the water condense trap “
A
”.
•
&OHDQWKHERWWRPRIWKHWUDSE\ÀXVKLQJLWRXWZLWKZDWHU
• Fill the lower section with water until about 10 mm below the upper
edge.
• Fasten the lower section onto the condense trap again.
'RQRWRSHUDWHWKHERLOHUZLWKHPSW\FRQGHQVHWUDSWRDYRLGULVN
RISRLVRQLQJWKURXJKWKHJDVFRPEXVWLRQV
18.2 CLEANING THE HEAT EXCHANGER FUMES SIDE
%HIRUHVWDUWLQJWRFOHDQWKHKHDWH[FKDQJHUZDLWXQWLOWKHWHPSHUDWXUHLVORZHUWKDQ&DQGSURWHFWDOOWKHHOHFWULFFRPSRQHQWV
DJDLQVWVSODVKHVRIZDWHU
Proceed as follows to clean the heat exchanger:
• Disconnect the boiler from the mains power supply.
• Close the gas inlet valve.
• Remove the front cover from the boiler.
• Lower the electrical box, ensuring it is protected against contact
with water.
•
'LVFRQQHFWWKHFDEOHVRIWKHLJQLWLRQHOHFWURGHWKHÀDPHVHQVLQJ
HOHFWURGHDQGWKHKHDWH[FKDQJHUÀDQJHWKHUPRVWDW
•
5HPRYHWKHIDQPL[HUEXUQHUÀDQJHDVVHPEO\XQVFUHZLQJWKH
nuts M6 and the connector under the mixer.
• Protect the rear insulating panel (2) against water with a waterproof
¿OPDYDLODEOHLQWKHFOHDQLQJNLW
• Accurately suck up the residue inside the combustion chamber and
remove any scale, using a brush with plastic bristles available in
the cleaning kit.
• Sprinkle the surfaces to be cleaned (1) generously with the
appropriate liquid BX-HT Cleaner or similar using the appropriate
spray bottle and wait 10 minutes (other products may be used,
after consulting the authorised technical assistance service).
Brush without rinsing and apply BX-HT Cleaner again. Let 10 more
minutes pass, then brush again. If the result is not satisfactory,
repeat the operation.
•
:KHQFOHDQLQJLV¿QLVKHGULQVHZLWKZDWHU
•
5HSODFHWKHJDVNHWRIWKHEXUQHUVXSSRUWÀDQJH
• To reassemble, proceed in the inverse order, tightening the 6 nuts
RIWKHÀDQJHZLWKDWRUTXHRI1P
CR_0510
A
1
2
Содержание LUNA DUO-TEC MP+ 1.115
