Bad Boy Mowers DIESEL 1500cc, Руководство владельца, обслуживания и запасных частей

Страница: 18 / 54

PAGE 18
SERVICE SECTION
SECTION 1: HYDROSTATIC SYSTEM
The hydraulic reservoir tank on the Diesel 1500cc model
is located under the seat. There is a dipstick that
indicates the current hydraulic oil level. Use only 20W-50
motor oil in this tank. Conventional or synthetic oil may
be used. Bad Boy Hydrostatic Oil is recommended. Bad
Boy recommends that the hydraulic oil and filters be
changed within the first 50 hours of use; then at intervals
of 250 usage hours. Use only Bad Boy replacement
filters. Use of any other filters may result in damage to the
hydraulic system and void the warranty. Each side
requires approximately two quarts of oil to refill the
system.
THE FOLLOWING MAINTENACE IS TO BE
PERFORMED ON A LEVEL SURFACE.
CHANGING YOUR HYDRAULIC OIL AND FILTER
1
.
Place an oil drain pan under the engine plate and
place the hydraulic return lines that go into the
top of the hydraulic reservoir tank into the oil pan.
Remove the cap from the hydraulic reservoir
tank.
2. Start the engine in order to cycle out the old
hydraulic oil.
3. When you see air bubbles in the hydraulic lines
immediately shut off the mower. Keep in mind
that only 75-80% of the hydraulic oil can be
changed at a time.
4. Place rags under the hydraulic filters. Turn the
hydraulic filters counter clockwise to remove.
5. Fill the new hydraulic oil filters with 20W-50
motor oil. Only use Bad Boy replacement filters.
6. Place the hydraulic return lines back onto the
hydraulic reservoir tank. Fill the hydraulic
reservoir tank until the oil level reaches the
bubble on the dipstick. Be careful not to overfill
the hydraulic reservoir tank.
7) Proceed to the purge procedure.