Bad Boy 1500G, Руководство владельца и каталог запасных частей

Страница: 9 / 32

Instructions for changing engine oil filter:
• Drain engine oil out.
• Install oil filter.
• Add oil to crankcase (UTV by Bad Boy Engine Lubricant SAE 10w40: part number 785-1030-00)
• Engine oil capacity: 3500/3860c.cc
• Install dipstick, run the engine for several minutes.
• Turn off the engine and check oil level again.
• Check for any engine oil leaks.
Differential Oil
Instructions for changing:
• Remove oil filler bolt.
• Remove drain plug and drain gear oil.
• Install the drain plug.
• Make sure that the drain bolt washer can be reused or replaced.
• Add oil to specified quantity.(oil viscosity SAE 80-90#)
• Gear Oil Quantity: 300-350ml.
Fuse and Battery
In order to access the battery or to replace the fuse, you first remove the seat. Under the seat on the driver’s side, you will find
the fuses.
note: Only install the correct fuse for replacement. If the fuse should fail several times, you should immediately consult your
authorized dealer.
Instructions for installation:
• Lift the seat. You can see the battery. The battery is a sealed type. You can take it to you dealer to check the
battery’s charge condition periodically. In order to remove the battery, loosen the bolts from the battery clamp then remove the
battery. When the battery needs to be recharged, use 1.8A current for 5-10 hours. Maximum charging rate: 9A x 1 hr.
Reversing the battery lead wires can harm your UTV, the battery and\or the charging system.
• When connecting the battery, connect the red wire with the mark (+) and the black wire with the mark (-) of the
battery,
note
: connect the red wire (+) first, then the black wire (-).
Disconnect the battery when not in use for long periods of time.
attention
: The maximum power consumption must not exceed 5a.
PAGE 9