INSTRUCTIONS FOR THE DEALER
INSTRUCTIONS FOR THE DEALER
RST Futura
RST Futura
RED
BLUE
Pag. 2
Pag. 3
4
5
1
2
2
3
4
6
•
Fit the front stand (1) sliding it onto the rod hubs.
Make sure the right-hand spacer (4) and the left-
hand spacer (3) are properly positioned in their
housings.
Check the direction the wheel rotates in (see
arrows).
•
Fit the wheel and pin (2).
•
Fit the screws (5) of the left-hand rod terminal to
prevent the pin rotating.
•
Fit the washer (6) and secure the nut (7).
Screw (7) tightening torque: 59,0 ftlb (80 Nm).
•
Remove the stand.
1
2
3
4
5
6
7
IMPORTANT
FITTING THE FRONT WHEEL
Before carrying out any maintenance operation or
inspection of the front wheel, if possible hoist the
vehicle onto a solid and level surface with suitable
equipment.
When disassembling and reassembling the front
wheel, take extra care not to damage the brake
lines, discs or pads.
IMPORTANT To fit the front wheel, you may require a
helper.
DANGER
FITTING THE BATTERY
•
Make sure the ignition
key is in the “
“ position.
•
Place the battery into its housing.
•
First connect the positive cable (+ red) then the ne-
gative (- blue).
•
Make sure the two attachments (6) of the positive
and negative poles are fitted towards the outside of
the battery as shown in the diagram.
•
Cover the terminals and lead ends with neutral grease
or vaseline.
•
Fit the battery cover and secure with the screws (2)
TBEI M 5x16. Fit the saddle.
Screw (2) tightening torque: 1,47 ftlb (0,2 Nm)
CAUTION
CAUTION
INITIAL BATTERY CHARGING
•
Remove the saddle from its housing turning the key
(1) clockwise.
•
Remove the two screws (2) TBEI M 5x16 from the
battery compartment cover (3) and remove the
battery.
•
Detach the battery recharge container (5) from the
license plate holder and remove the plug (4).
•
Fit the battery container as shown in the drawing.
•
Use the same plug (4) to close up battery holes.
CAUTION
BATTERY
DANGER
Battery electrolyte is toxic, caustic and the contact
with the skin may cause serious burns, since it
contains sulfuric acid. Wear protective clothing, a
face shield and/or tight fitting goggles when
working around the battery. In case of contact with
the skin, flush immediately with plenty of water.
In case of contact with the eyes, flush with plenty
of water for at least 15 minutes. Immediately
consult an optician.
If the electrolyte is accidentally swallowed, drink
large quantities of water or milk, and then milk of
magnesia or vegetable oil. Immediately consult a
health professional. The battery gives off noxious
and explosive gases; keep it away from cigarettes,
flames, sparks and any other source of heat.
During the recharging or the use, make sure that
the room is properly ventilated and avoid inhaling
the gases released during the recharging. KEEP
AWAY FROM CHILDREN. Do not tip the vehicle too
much, or tip the battery too much, to avoid
electrolyte leaking out.
The battery liquid is corrosive. Do not pour or
sprinkle it, particularly on plastic parts. When the
battery has been removed it must be placed in a
safe place out of the reach of children. The battery
is very dangerous and may cause serious injury
or death.
CAUTION
