cLEAnIng InSTRUcTIonS
Tires: The tires should be cleaned with ordinary kitchen-type cleaners and a damp cloth.
Don’t use solvents on tires as they cause tire material to break down or become too soft.
Platform: the platform of the amigo is constructed of aluminum and coated with a durable automotive type finish.
use cool water with mild soap to remove dirt and oils. do not spray the entire vehicle with water. this will
damage the electrical parts. The platform may be waxed with car body wax and buffed by hand with a soft cloth.
Seat: the vinyl seat can be cleaned with a mild soap or detergent and a damp cloth. a vinyl cleaner
can also be used. Care should be taken not to soak seats, as the interior foam rubber will hold water.
floor mat: The floor mat should be cleaned with ordinary kitchen-type cleaners and a damp cloth.
Do not use solvents on the floor mat, as they may cause the floor mat material to break down.
KEEP CLEANINg SOLVENTS AWAY FROM ELECTRICAL WIRES AND CONNECTIONS.
MAInTEnAncE
minimum maintenance should prevent unnecessary repairs. you will get years of dependable
operation if you follow the suggested maintenance schedule. Check the following:
Daily
charge batteries daily when the amigo is used. charge the battery until fully charged to ensure
proper battery operation. Extended charging is good for the batteries and will not overcharge them.
Monthly
Check and clean battery terminals and the wire connections as needed with a
light piece of emery cloth or brush and soda water.
• Clean upholstery, plastic and metal with a mild surface cleaner.
• Inspect batteries for any cracks or damage of any kind.
• Check and tighten any exposed fasteners.
KEEP CLEANINg SOLVENTS AWAY FROM ELECTRICAL WIRES AND CONNECTIONS.
Six Months
• Check all screws and clips (that are holding wheels) for tightness and wear.
• Check all electrical connections for clean contact.
• Charging connection should be inspected for tight connection.
• Check tires for wear.
• Inspect inside the battery case, particularly at the bottom, for liquid.
Yearly
• Have your authorized service center check your Amigo completely.
Battery Maintenance
VRLA (Valve Regulated Lead Acid) deep cycle or optional lithium-ion batteries are used for operating your Amigo.
They are maintenance-free and are transportable on aircraft, buses, trains, etc. as there is no danger of spillage.
By following the charger and battery procedures, you can expect extended battery life.
Fasteners Replacement
Use only grade 8 (US) or 12.9 DIN (metric) in all applications. For service and
replacement parts, we recommend amigo authorized parts.
Microprocessor Controller (MPC)
do not attempt to service the mpc or related electronic components, as this will void the warranty.
Fuse Replacement Instructions
an auto reset fuse protects the wiring and battery in the event of a short circuit. if your amigo stops abruptly,
wait 10 seconds for automatic fuse to reset. If the fuse does not reset, check for overloads or short circuits.
if you suspect the auto reset fuse is defective, use a jumper wire between the two terminals of the fuse.
if the amigo runs now, replace the auto reset fuse.
Battery Replacement
note: replacement battery must meet passenger
and cargo aircraft travel requirements.
• Remove four screws as shown
and remove battery front cover.
• Remove the black wire from each battery.
• Lift each battery far enough to expose
the red wire connection and remove it
from each battery.
• Reverse this sequence to install batteries.
NOTE:
Tampering with electrical or
mechanical parts will void warranty.
www.myamigo.com
11
10
1-800-248-9131
