AIR FILTER CLEANING
INSTRUCTIONS
1) PRE-CLEANING
Remove air filter from AIRSEP.
Tap filter element to dislodge
any large dirt particles. Gently
brush with a soft bristle brush.
2) SPRAY ON CLEANER
Spray liberal amount of cleaning
solution onto entire filter element
and allow to soak for 10 minutes.
3) RINSE OFF
Rinse off the element with low
pressure water. Always flush
from the clean side to dirty side.
This removes the dirt and does
not drive it into the filter.
4) DRYING THE FILTER
Always dry naturally. After
rinsing, shake off all excess
water and allow the element to
air dry naturally or in the sun.
5) RE-OILING THE FILTER
After cleaning air filter always
re-oil before using. Apply oil
down each pleat. Wait ten
minutes and re-oil any light
visible spots
6) CLEAN VACUUM REGULATOR/LIMITER
Using a slot head screwdriver, loosen clamp
and remove filter. Then follow steps 1 through
5. To clean the Vacuum Limiter do not attempt
to remove the filter. Remove the entire
vacuum limiter and follow steps 1 through 5.
7) AIR FILTER INSTALLATION
Reinstall air filter on AIRSEP. Use Walker
Air Filter Sealing Compound (CD955) when
reinstalling air filter. Be sure to inspect
springs and replace if worn.
Walker Engineering Enterprises, Sun Valley CA 91352
www.walkerairsep.com
©
2005 Walker Engineering Enterprises. All Rights Reserved.
CAUTION
NEVER CLEAN USING:
Gasoline
Part Cleaner Solvents
Caustic Cleaning Solutions
Strong Detergents
High Pressure Water
High Pressure Air
Steam Cleaners
NEVER OIL FILTER:
Using Transmission Fluid
Using Motor Oil
Using Diesel Fuel
Using WD-40
Using Other Oils
FAQ’s and Air
Filter Cleaning Tips
Made in U.S.A.
This kit cleans and oils up to four
(4) 9x12 or equivalent sized filters.
How often do I need to clean my
air filter?
You should clean your
air filter every 250 to 300 hours, or
every year whichever comes first.
How often should I replace my air
filter?
Replace your air filter after
four (4) cleanings or every 3 or 4
years depending on condition of
filter.
Is it better for my engine if I clean
the air filter more often?
No,
follow the cleaning interval listed
above. Cleaning too often will
impair the vacuum action of the
AIRSEP.
Can I use other liquids to clean
and oil my air filter? No,
your
AIRSEP air filter may be damaged
by harsh detergents or liquids other
than the recommended cleaner in
this kit. Other oils may be too light
or too heavy to properly capture
airborne dirt. Use the appropriate
Walker kit to clean and recondition
your standard or blue air filters.
� � �� � � �� � � �� � � � �� � �� � � � � � � �� � �
Содержание Walker Ford / Lehman
Страница 2: ......
