Afikim Afiscooter-C, Руководство пользователя

Страница: 29 / 32

``
29
CHAPTER 9
– TROUBLESHOOTING AND REPAIR
The following table provides troubleshooting and repair instructions for problems that may
be encountered when operating
AFISCOOTER C
, as well as the best way to correct the
problem. The table contains three columns:
Symptom Probable Cause Remedy
The problem you are
experiencing The most likely causes, in order of
probability (most likely first) Recommended action to
correct each probable cause
Remember : you can contact your dealer at any time for further professional support.
Remark :

For troubleshooting repairs, the only tools needed are regular and Philips
screwdrivers to open the rear lights covers, to replace the bulbs if burnt.

Replacement parts :

Tires and tubes are: 4.10/3.50
–6" (all models)

Headlight bulb: 24V/25W

Rear light bulb: contact your authorized dealer
No. Symptom Probable Causes Remedy
1 Flat tire and unstable driving.

Low air pressure

Puncture

Pump tire to normal pressure

Repair tire
2 The LEDs flash and the
vehicle does not move.

(identified by the fault
code)

Call for technical support
3 Handbrake is fully engaged
but the vehicle does not stop.

Loose handbrake
mechanism

Tighten the brake cable
4 When throttle control lever is
released on a level surface,
AFISCOOTER C takes longer
than 3 meters to stop.

Controller is faulty or
out of adjustment

Call for technical support
5 Key switch is turned ON but
the ON light does not come
on.

Main fuse (2.1a in
Fig. 1) popped

Electrical fault

Reset fuse
Note: Do not reset fuse more than twice.
If the symptom still recurs, call your
authorized dealer for support.
6
AFISCOOTER C does not
move when you squeeze the
throttle control lever.

Key switch is OFF

Charger is connected
to charging socket

Handbrake is on

Control system failure

Turn key switch ON

Disconnect charger

Take off handbrake

Call for technical support
7 Intermittent drive.

Battery capacity is low

Faulty connections

Faulty battery

Charge batteries for at least 18 hours

Remove battery cover and check
battery connection. If terminals are
corroded, clean them with a damp,
clean cloth

If red LEDs are still on, contact your
dealer for a replacement battery
8 Right or left indicator light is
inoperative.

Faulty LED light board

Replace LED board
9 Headlight or rear light does
not light.

Burnt out bulb

Replace bulb
10 When driving uphill or
carrying heavy loads , speed
reduces gradually (but
scooter still moves).

Controller became
overheated

Stop driving and let controller cool