MUFFIN TOASTER MT-12
10
P/N 1010610 Rev. Q 07/16
McDonald’s
OPERATION (continued)
MAINTENANCE
Hi-Limit Reset Button
A hi-limit thermostat will turn off electrical power to the
heater and control circuits if the unit overheats. To
reset the thermostat, allow sufficient time (about 45
minutes) for the unit to cool down, remove the cap and
press the red reset button located on the side of the
unit (Figure 2).
If the unit requires continuous resetting, contact your
Authorized Service Agency.
Figure 2. Hi-Limit Reset Button
Partial
Load
READY
Hi-Limit Reset Button
WARNING
Turn the power off, unplug the power cord, and allow
the unit to cool down before performing any service or
maintenance.
WARNING
Inspection, testing, and repair of electrical equipment
should only be performed by qualified service
personnel.
CAUTION
Chlorides or phosphates in cleaning agents (e.g.
bleach, sanitizers, degreasers, or detergents) could
cause permanent damage to stainless steel
equipment.
The damage is usually in the form of discoloration,
dulling of metal surface finish, pits, voids, holes, or
cracks.
This damage is permanent and not covered by war-
ranty. The following tips are recommended for mainte-
nance of your stainless steel equipment:
• Always use soft, damp cloth for cleaning, rinse with
clear water and wipe dry. When required, always
rub in direction of metal polish lines.
• Stains and spots should be removed using a
vinegar solution.
• Finger marks and smears should be rubbed off
using soap and water.
CAUTION
If a chemical cleaner is used, be sure it is safe to use
on cast aluminum. Observe all precautions and warn-
ings on product label.
Maintenance Schedule
DAILY – CLEAN CRUMB TRAY
1. Turn the power switch to the off position. Unplug
the power cord from the wall. Allow the toaster
and plate to cool for at least 30 minutes.
NOTE: The muffin toaster may be hot. Make sure
the toaster and plate are cool enough to handle
before you begin cleaning.
2. Put on neoprene gloves. Remove the Spatula
and set aside. Then, lift the Crumb Tray to
remove it from the muffin toaster. Remove the
Plate from the Crumb Tray.
3. Use a clean, sanitizer soaked towel to wipe the
surface of the Plate.
4. Inspect the Plate for carbon build-up. Wipe the
plate with a clean, damp cloth. IF the plate has
excessive carbon build-up, apply McD Hi-Temp
Grill Cleaner to the grill surface. Wipe the grill
surface with a clean, sanitized grill cloth. Rinse
the grill surface with water. Wipe the grill with a
clean, sanitized towel to remove all cleaner resi-
due.
5. Using a clean, sanitize towel, wipe the crumbs
from the Crumb Tray. If necessary, wash the
Crumb Tray and spatula at the 3 compartment
sink.
8. Place the Plate back onto the Crumb Tray. Slide
the Crumb Tray into the muffin toaster. Then
place the Spatula into the muffin toaster
NOTE: The Plate is reversible. Rotate the Plate from
side-to-side between cleanings. This extends the
life of the Plate.
