NSS BP27 ULTRA MAXX, User Manual

Page: 1 / 20

BP27 ULTRA MAXX
IMPORTANT SAFETY INSTRUCTIONS
READ AND UNDERSTAND ALL INSTRUCTIONS
BEFORE OPERATING OR SERVICING MACHINE
DANGER !
Failure to Observe These Instructions Can Cause Personal Injury
to Machine Operator, By-Standers or Possible Machine Damage.
•
ALWAYS wear eye protection and protective clothing when working with the batteries.
•
The batteries contain ACID . Avoid contact with skin or clothing.
•
Antidote: EYES - Flush with water 15 minutes. Call physician.
INTERNAL - Drink water or milk. Follow with Milk of Magnesia, beaten egg or vegetable oil. Call
physician.
•
Service should be done only by authorized, trained personnel.
•
Charge Batteries in a well ventilated area with Battery Compartment Open.
•
Batteries generate explosive gasses - keep sparks, flames, burning cigarettes or other ignition sources away
at all times.
•
Batteries are heavy - two (2) people are required for installation or removal.
•
Never lay anything on top of batteries to prevent arcing.
•
Turn off all switches during installation and service.
•
To maintain machine balance, always slide batteries back into position as shown on battery installation decal.
•
Connect batteries as shown on battery installation decal to avoid shorting out batteries and electrical system.
•
Disconnect battery leads before performing any service or repairs.
•
ALWAYS make sure battery charger is turned off when connecting/disconnecting to machine to prevent
sparking.
•
ALWAYS operate this machine from the rear control panel, not from the side.
•
NEVER operate machine in an explosive atmosphere (grain dust or gas vapor).
•
NEVER use flammable liquids (gas, kerosene, solvents or thinners) to clean floor.
•
ALWAYS turn off master switch when changing pads.
•
NEVER operate machine with skirts or covers removed.
•
NEVER leave machine unattended.
PERSONAL INJURY AND PROPERTY DAMAGE FROM MACHINE OVERTURNING, BATTERIES FALLING
OUT OF MACHINE OR BATTERIES LEAKING ACID CAN OCCUR IF YOU DO NOT FOLLOW THESE
PRECAUTIONS:
•
NEVER attempt to operate machine unless you have been trained in its operation.
•
Follow these rules when working on or near loading docks and ramps:
•
ALWAYS be sure ramp is secured to vehicle before attempting to load/unload.
•
ALWAYS use extreme caution when operating machine on a ramp or loading/unloading a machine into or out
of a truck. Use extreme caution if ramp is wet, oily or covered with cleaning chemicals.
•
NEVER turn machine on an incline.
•
NEVER stop machine on a ramp.
•
NEVER attempt to climb a grade of more than 20 degrees.
•
NEVER park machine near a dock or on ramps.
•
NEVER leave machine unattended.
WARNING: Failure to observe these instructions can cause machine damage and possible personal
injury to machine operator.
•
NEVER spray machine with water.
•
NEVER allow battery charging plugs to get wet. Battery charging plugs will short out if wet.
•
NEVER operate machine when charger is plugged in.
•
NEVER store machine near furnaces, boilers or flame which may damage machine.
•
NEVER store any item on the machine.
•
ALWAYS protect machine from freezing temperatures.
SAVE THESE INSTRUCTIONS
https://harrissupplyind.com - To Order Parts Call 608-268-8080