158AG11857
ITEM
PT. NO.
DESC.
QUAN.
DR.: SRB 11/302004
INTERMATIC INCORPORATED
CHKD.: DF 11/30/2004
SCALE NAME:
INST SHT - AG2401C-IND
APPROVED
MATL.:
WHITE PAPER STOCK
RM 11/30/2004
FINISH:
BLACK PRINTING INK
1 RELEASED TO ELECT. DATA
HEAT TREAT:
LET.
REVISION
SIGN.
MODEL
ASSEM.
QUAN.
SUPERSEDES:
120/240 VAC Three wire
Found at Service entrances and
Meter Cans.
WHITE
BLACK
BLACK
120/240 VAC Three wire plus Ground
Found in Main Disconnect Switches,
Main Distribution panels, Load Centers
Sub panels and equipment locations.
240 VAC Two wire plus Ground
from a single phase panel
Found at connections for individual
pieces of equipment such as motors,
water heaters and parking lot lights.
BLACK
BLACK
120 VAC Three wire single phase
Found at connections for individual
pieces of equipment such as pumps
and single phase motors. NOTE:
This configuration provides and neutral-to-ground protection.
WHITE
WHITE
BLACK
BLACK
158AG11857
INTERMATIC INCORPORATED
PLAZA, SPRING GROVE, ILLINOIS 60081-9698
© Copyright
2004 Intermatic Inc.
Model AG2401C-IND
Secondary Surge Arrester
INSTALLATION
INSTRUCTIONS
WARNING:
HAZARDOUS VOLTAGES MAY BE PRESENT. Improper installation of this device could result in ELECTRIC
SHOCK, BURN or EXPLOSION. Intermatic Incorporated recommends that the AG series Secondary Surge
Arresters be installed by a licensed electrician. Hazardous voltages may be present. AG series units are not
intended to protect against direct lightning strikes.
OPERATION:
The LED indicator lights should be 'ON' indicating proper operation. If one or more lights are 'OFF', check for
loss of one or more phases of AC power. If AC power is present, the unit is no longer providing surge protection
and should be replaced.
APPLICATION:
This model is designed for single phase applications with line voltages of 120/240 VAC. If your application does
not match one of the diagrams shown below, consult the information on the back of this sheet or call your supplier.
AG Series devices are not intended to protect against direct lightning strikes.
WHITE
BLACK
BLACK
FRA .010 . DECIMALS AS SPECIFIED - 1/2˚
ALL DIMENSIONS MUST BE MET BEFORE PLATING.
DIM :
TOL
NOTES:
ALL PRINTING TO BE AS PER INTERMATIC
APPROVED ARTWORK.
11”
8.
5
”
FOLD
LINES
(TYP)
FRONT
BACK
SEE B/M FOR ALL PART NUMBERS & QUANTITIES
TEN YEAR LIMITED PRODUCT WARRANTY
For
INTERMATIC
®
AG - IND SERIES SURGE ARRESTERS
(1) What Is Covered By This Limited Warranty
Repair or Replacement of Product
Intermatic Incorporated ("Intermatic") warrants to the original purchaser only, Intermatic models AG2401C-IND and
AG6503C-IND, Surge Arresters (each a "Product") shall be free from defects in material or workmanship for a period of
ten years (120 months) from date of purchase or 126 months from date of manufacture. If the purchaser discovers a
defect in material or workmanship, the purchaser must promptly submit a warranty claim. Upon a determination by
Intermatic that the Product is defective, Intermatic, at its sole option, shall correct any defect in material or workmanship
by either repairing or replacing the Defective Product. The foregoing remedies are the purchaser's exclusive remedies
for a breach of warranty.
The Product must be installed in the appropriate application in complete accordance with the installation instructions. All
building wiring and other connections to the Product must conform to all applicable national, state and local electrical
codes; the Product must not be opened, modified, exposed to extreme heat or cold, submerged or subjected to abnor-
mal use or service. All products must be used in accordance with the instructions provided with the Product and the
purchaser shall be solely responsible for selecting a Product model with specifications appropriate for the equipment to
be protected. Intermatic shall determine, in its sole discretion, whether any Product returned by a purchaser has been
used in accordance with its instructions, is an appropriate model for the purchaser's use thereof, and whether the
Product is defective.
(2) What Is Not Covered By This Warranty
Intermatic does not warrant (a) defects in the Product or damage to any equipment caused by the failure to properly
install the Product, (b) damage caused by use of the Product for purposes other than those for which it was designed,
(c) damage caused by disaster such as fire, flood and wind, (d) damage caused by unauthorized attachments or modifi-
cation of the Product, (e) damage to the Product occurring during shipment, (f) electrical disturbances exceeding pub-
lished product specifications, or (g) damage to the Product caused by any other abuse or misuse by the purchaser.
This product is not designed to protect against Utility swells, loss, restoral or abnormal sustained overvoltage conditions
or voltage conditions caused by loss or high impedance neutral.
(3) Disclaimer of Warranty
THE FOREGOING WARRANTIES ARE IN LIEU OF ALL OTHER EXPRESSED WARRANTIES. TO THE EXTENT
ALLOWED BY LAW, ANY IMPLIED WARRANTIES OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR
PURPOSE ARE LIMITED IN DURATION TO THE DURATION OF THIS LIMITED WARRANTY.
(4) Limitation of Remedies
IN NO CASE SHALL INTERMATIC BE LIABLE FOR ANY SPECIAL, INCIDENTAL, OR CONSEQUENTIAL DAMAGES
BASED UPON BREACH OF WARRANTY, BREACH OF CONTRACT, NEGLIGENCE, STRICT TORT, OR ANY OTHER
LEGAL THEORY. SUCH EXCLUDED DAMAGES INCLUDE, BUT ARE NOT LIMITED TO, DAMAGE TO SOFTWARE,
LOSS OF DATA, LOSS OF PROFITS, LOSS OF SAVINGS OR REVENUE, LOSS OF USE OF THE PRODUCT OR
ANY ASSOCIATED EQUIPMENT, COST OF CAPITAL, COST OF ANY SUBSTITUTE EQUIPMENT, FACILITIES OR
SERVICES, DOWNTIME, THE CLAIMS OF THIRD PARTIES INCLUDING CUSTOMERS, DAMAGE TO PROPERTY
AND PERSONAL INJURY. SOME STATES DO NOT ALLOW LIMITS ON WARRANTIES OR ON REMEDIES FOR
BREACH IN CERTAIN TRANSACTIONS. IN SUCH STATES, THE LIMITS IN THIS PARAGRAPH AND IN PARA-
GRAPH (3) MAY NOT APPLY.
(5) Time Limit for Bringing Suit
No action arising out of any claimed breach of warranty may be brought more than one year after the cause of action
has occurred.
(6) No Other Warranties
Unless modified in writing signed by both parties, this agreement is understood to be the complete and exclusive agree-
ment between the parties, superseding all prior agreements, oral or written, and all other communications between the
parties relating to the subject matter of this agreement. No employee of Intermatic or any other party is authorized to
INTERMATIC INCORPORATED
SPRING GROVE, ILLINOIS 60081
http://www.interrmatic.com
© Intermatic Incorporated 2004
