Yamaha DR2E PTV 2019, Owner'S/Operator'S Manual

Page: 7 / 60

1
2
3
4
5
6
7
8
9
10
11
WARRANTY
1-2
J0E
Yamaha Golf-Car Company (herein referred to as “YGC”) hereby
warrants to the Original Retail Purchaser or Lessee of a YAMAHA The
Drive golf car or PTV, Adventurer utility vehicle, or YAMAHA Concierge
transportation or specialty car purchased from Yamaha, or an
Authorized Dealer or Distributor in the United States, that the
Trojan
batteries charged with a YAMAHA battery charger will be free from
defects in materials and workmanship, and will provide “36-hole
performance” as follows:
s
4-years or 23,500 amp-hours with T-875
s 4-years or 25,000 amp-hours with T-875 batteries & the addition of
a factory-installed Trojan HydroLink Battery Watering System.
WARRANTY LIMITATIONS
Yamaha Golf-Car Company’s and Trojan Battery Company’s limit of
liability shall be to replace a defective battery. Replacement shall
mean furnishing a new battery or used battery with sufficient life to
complete the remainder of the warranty term, at no cost to the
purchaser during the limited warranty period, except for labor or
transportation expenses.
The following conditions apply:
s Amp-hours will be determined either through the Genius controller
or through other means as necessary in the event of a controller
failure or replacement.
s This warranty only applies to factory installed Trojan battery sets
charged with a Yamaha battery charger.
s The customer must perform (or have a contracted Yamaha Dealer
perform) all periodic maintenance and discharge testing as
specified in the Yamaha Service Manual Maintenance Schedule.
No labor or transportation expenses are included in this limited
warranty. Maintenance records must be kept.
s YGC supplied or approved replacement batteries may be of a
different brand or capacity, but are warranted to provide 36-hole
performance for the remainder of the original warranty term.
s “36-hole performance” is defined as 60-minutes discharge time as
tested and recorded using a Lester model #17770 discharge
machine at an ambient temperature of between 60 and 100
degrees F (16 and 38 degrees C). Ambient temperatures
between 60 and 80 degrees F (16 and 27 degrees C) must be
corrected using the formula: Adjusted Discharge Time =
(Discharge Minutes) / (1-(((80-TEMP)/100) x 0.64)).
s
The customer must notify the Dealer within 10 days that a vehicle
has failed to make 36 holes per day. YGC reserves the right to
test and recharge any battery in question.
ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS
FOR A PARTICULAR PURPOSE SHALL BE VOID AND EXCLUDED
SUBSEQUENT TO ONE YEAR FROM THE DATE OF PURCHASE.
THE REPLACEMENT OF THE BATTERY IS THE EXCLUSIVE
REMEDY UNDER THIS WRITTEN WARRANTY OR ANY IMPLIED
WARRANTY. YAMAHA MAKES NO OTHER REPRESENTATION
OR WARRANTY OF ANY KIND, AND NO REPRESENTATIVE,
EMPLOYEE, DISTRIBUTOR OR DEALER OF YAMAHA HAS THE
AUTHORITY TO MAKE OR IMPLY ANY REPRESENTATION,
PROMISE OR AGREEMENT WHICH IN ANY WAY VARIES THE
TERMS OF THIS LIMITED WARRANTY.
LIMITED WARRANTY EXCLUSIONS
Without limiting the generality of the foregoing in any way, and as
part of its limited warranty exclusion, YAMAHA does not warrant
that its battery is suitable for use in any application other than in a
golf car or utility vehicle. As in the use of any battery, a prudent
owner will read and study the charger owner’s manual, the vehicle
owner’s manual, the operator’s instructions, and the battery warning
labels; and will exercise due care in working on or around batteries.
THE PROVISIONS OF THIS LIMITED WARRANTY SHALL
NOT APPLY IF BATTERIES ARE SUBJECTED TO ANY OF
THE FOLLOWING CONDITIONS:
s Abuse or neglect such as improper fluid levels, loose wiring,
rusted or corroded hardware.
s
Lack of proper maintenance as outlined in the electric vehicle
Owner’s/Operator’s Manual. For example, lack of regular
battery watering or adding water to the battery before
charging.
s Damage caused by improper installation of the battery.
s Neglect, breakage, freezing, fire, explosion, wreckage, the
addition of any chemical, or the operation of the battery in an
uncharged condition (below half-charge – 1.200 specific
gravity).
s Battery charged by systems other than the original equipment
type battery charger.
s
On fleet golf cars, the use of any non-YAMAHA supplied
electrical devices that consume more than one amp-hour per
round or two amp-hours per day of battery energy. Examples
of these devices include, but are not limited to: heating or
cooling systems; GPS (global position system) devices;
information gathering devices; lights; radios or stereos; or
yardage measuring devices.
s Less than one charger per car or inadequate facility electrical
power to power all chargers. Examples include more than
one charger on a single circuit, circuit rating of less than 15
amps, or not enough circuits for the number of cars.
s
In fleet applications, less than one battery charger per vehicle.
For example, using only 10 battery chargers to charge a 15
car fleet.
s The use of any system that does not allow the battery
chargers to shut off automatically. For example, timer
systems that are designed to switch battery charger AC power
on and off during peak demand hours.
s Damage not resulting from a defect in materials or
workmanship or which occurs due to abuse or neglect
(including failure to provide reasonable and necessary
maintenance), accident, alteration or acts of God is excluded
from this limited warranty.
THIS BATTERY IS INTENDED TO BE USED BY PERSONS
WITH TRAINING AND EXPERIENCE WITH BATTERIES AND
ONLY IN YAMAHA ELECTRIC VEHICLES. ANY OTHER USE
RENDERS THE LIMITED WARRANTIES EXPRESSED HEREIN
AND ALL IMPLIED WARRANTIES NULL AND VOID AND SAME
ARE HEREBY EXCLUDED.
ALSO EXCLUDED FROM THIS LIMITED WARRANTY ARE
ANY AND ALL INCIDENTAL OR CONSEQUENTIAL DAMAGES
INCLUDING, BUT NOT LIMITED TO, LOSS OF USE OR
REVENUE, LOSS OF TIME, INCONVENIENCE OR ANY
OTHER ECONOMIC LOSS.
Some states do not allow limitation on the duration of an implied
warranty, exclusions or limitations of incidental or consequential
damages. Therefore, the above limitations or exclusions may not
apply to you.
This warranty gives you specific legal rights, and you may also
have other rights, which vary from state to state.
For further information or to submit a warranty claim, contact your
local Yamaha Golf-Car Dealer or Yamaha’s customer relations.
EFFECTIVE DATE: 07/01/16 LIT-13710-EL-14
YAMAHA FOUR-YEAR LIMITED WARRANTY FOR TROJAN BRAND
ELECTRIC GOLF CAR AND UTILITY VEHICLE BATTERIES WHEN
CHARGED WITH A YAMAHA SUPPLIED 48-VOLT CHARGER
1270 Chastain Road
Kennesaw, Georgia 30144
1-866-747-4027
©
2019 Yamaha Golf-Car Company