19
16. Remove quarter inch by seven inch pins from top and bottom holes.
17. Set parking brake and start the engine (set throttle at full speed). Make sure that the PTO is off.
18. Rotate rods (lengthen or shorten) to bring each hydrostat to neutral.
NOTE:
The control linkage going to the hydrostatic pump has left-hand threads at the pump and right-hand
threads at the tower.
19. Tighten the jam nuts earlier loosened.
20. Reassemble safety switches.
21. Reassemble body panels.
22. Reassemble drive handle assembly.
23. Make sure that all hardware is tightened.
SECTION 7: LUBRICATION
Use the two tables that follow for lubrication details. The first table is for oil details and the second table is for
grease point information.
Oil
Check
Change
Capacity
Type
Engine crankcase
See Engine Operator’s Manual Section
Hydraulic units
50 Hours
500 Hours
9.5 Quarts
Part Number 737-0305 (10W40 motor oil)
Grease Point
When to Grease Type of Grease
Caster Ass’y - 3 fittings (1 on each
wheel spindle and one on middle of
caster assembly)
50 Hours
Two strokes (minimum) of lubricator using 251 H EP grease or
equivalent No. 2 multipurpose lithium grease (refer to SECTION
8: MAINTENANCE on page 21 for locations)
Caster wheels - 2 fittings (1 on each
wheel)
50 Hours
Two strokes (minimum) of lubricator using 251 H EP grease or
equivalent No. 2 multipurpose lithium grease (refer to SECTION
8: MAINTENANCE on page 21 for locations)
Control Tower - 2 fittings
(Right side of tower)
50 Hours
Two strokes (minimum) of lubricator using 251 H EP grease or
equivalent No. 2 multipurpose lithium grease (refer to SECTION
8: MAINTENANCE on page 21 for locations)
Deck Lift Pivot
50 Hours
Two strokes (minimum) of lubricator using 251 H EP grease or
equivalent No. 2 multipurpose lithium grease (refer to SECTION
8: MAINTENANCE on page 21 for locations)
Lift Handle
50 Hours
Two strokes (minimum) of lubricator using 251 H EP grease or
equivalent No. 2 multipurpose lithium grease (refer to SECTION
8: MAINTENANCE on page 21 for locations)
Mower Deck
50 Hours
Two strokes (minimum) of lubricator using 251 H EP grease or
equivalent No. 2 multipurpose lithium grease (refer to SECTION
8: MAINTENANCE on page 21 for locations)
