I pg 06
Plumbing Connection
1. Connect the pipe extending from the pump outlet to the inlet of the MultiCyclone Plus/Ultra.
2. Connect from the pipe extending from the outlet of the MultiCyclone Plus/Ultra to the next
component in line with the filtration system or water return line.
3. Glue all plumbing to barrel union fittings in accordance with glue (solvent) manufactures
specifications and allow 24 hours to set. Ensure glue (solvent) is not excessively applied to
fittings as this could run onto “o”-rings and create sealing problems.
Note:
Waterco recommends that a shut off valve be installed after the MultiCyclone Plus/
Ultra on the pool return line to assist with flushing out the collected debris. Please refer to
“Insufficient Water Pressure”.
4. Turn on pool pump. Be sure to check that there are no leaks from the connectors. If required,
tighten by hand.
START UP PROCEDURES
The MultiCyclone Plus/Ultra is an advanced and highly efficient filter system that will provide
years of trouble free service if the following maintenance procedures are maintained.
To start up the filtration system either from new or after cleaning is exactly the same.
1. Ensure that the MultiCyclone Plus/Ultra is plumbed correctly.
2. Ensure that all valves installed before and after the MultiCyclone Plus/Ultra are open.
3. Loosen the air release valve on top of the MultiCyclone Plus/Ultra filter lid.
4. Prime the swimming pool pump.
(Refer to the pump installation and operation manual)
.
5. Turn on the swimming pool pump and allow the pump to run until all the air has been expelled
from the MultiCyclone Plus/Ultra. Water will run from the air release valve.
6. Re-tighten the air release valve.
7. The filter is primed and ready for operation.
Note:
In some cases this may be required to be done a few times before the unit will remain
primed and be fully operational.
Do not stand over the lid of the MulitCyclone Plus/Ultra whilst adjusting the air release
valve to purge the system of air.
Injury may occur if air release valve becomes loose.
!
MultiCyclone Plus/Ultra
