EN
Quick Start Guide
TX-LTE-WLAN – Extension module
For your safety
Intended use
The extension module TX-LTE-WLAN is a wireless modem plug in for the HMIs
of the TX700 series and enables the TX7… to communicate with machines and
systems via the internet. The device may only be used as described in these
instructions.
Any other use is not in accordance with the intended use. Turck accepts no li-
ability for any resulting damage.
General safety instructions
■
The device may only be assembled, installed, operated, parameterized and
maintained by professionally-trained personnel.
■
The device only meets the EMC requirements for industrial areas and is not
suitable for use in residential areas.
■
The device may only be used in accordance with applicable national and
international regulations, standards and laws.
■
Only operate the devices in areas where the operation of wireless equipment
is allowed.
■
Any extended stay within the area the WLAN antenna may be harmful to
health. Maintain radiation limits and minimum distances when selecting the
installation location for the antenna.
■
The radiation WLAN antenna may impair the operation of medical equip-
ment. Maintain an additional distance from active radiation sources up to the
maximum transmission distance.
■
When installing the antenna outside: Observe lightning protection e.g. ac-
cording to EN 62305.
■
Switch off the device when working on the antenna.
Product description
Device overview
See fig. 1
Functions and operating modes
TX-LTE-WLAN is a is a 4G radio modem for LTE Cat.4 mobile networks. The
extension module provides four LED indicators for module and network status
and a microSIM slot. In addition, the TX-LTE-WLAN provides two digital inputs
and two digital outputs.
Connectors and slots
See fig. 1
Connector/slot
Function
1
LTE main antenna
2
GNSS antenna
3
LTE RX diversity antenna
4
Wi-Fi antenna
5
Expansion slot for plug-in modules
6
SIM card slot
7
LED displays 1…4
8
I/O channels
NOTE
The antennas are not included in the scope of delivery. Suitable antennas can
be found as accessories on the Internet at
www.turck.com
.
The I/O channels are SELV (Safety Extra Low Voltage) according to European
standards.
Installing
WARNING
Influences on lightning protection zone concept
Personal injury and material damage due to lightning strikes
➤
When installing the antenna outside: Observe lightning protection e.g.
according to EN 62305.
➤
Do not override lightning protection zone concept by the antenna and its
feed line.
➤
Remove the protective cover before installation.
➤
Mount the module according to fig. 2.
➤
Connect the supplied antenna (see Fig. 1).
ATTENTION
Risk of short circuits
Destruction of electronics!
➤
Do not connect or disconnect the device when energized.
WARNING
Influences of radio signals on the body
Personal injury due to radio signals
➤
Keep a minimum distance of 20 cm to persons.
Connecting
See fig. 3
➤
Connect a suitable antenna directly or via an antenna line.
➤
Observe the maximum length of the antenna cable (3 m).
➤
Do not ground the antenna.
DANGER
Effect on electrically controlled medical devices such as pacemakers
Danger to life due to malfunction or failure of medical equipment
➤
Maintain an additional distance from active radiation sources up to the
maximum transmission distance.
Power supply
The device is supplied via the plug in connection at the TX700.
Digital sensors and actuators
➤
Connect sensors and actuators according to the following pin assignment
using the supplied plug connector.
Pin
Signal
Pin
Signal
1
OUT 1A
5
IN 1+
2
OUT 1B
6
IN 1-
3
OUT 2A
7
IN 2+
4
OUT 2B
8
IN 2-
Operating
LED description
See fig. 4
LED
Description
1
Configurable
2
Configurable
3
Modem status ON/OFF
4
Netlight (network status LED)
Maintenance
➤
The devices must be cleaned at regular intervals with a damp cloth.
Repair
The device must not be repaired by the user. The device must be decommis-
sioned if it is faulty. Refer to our return acceptance conditions when returning
the device to Turck.
Disposal
The device must be disposed of correctly and must not be included in
normal household garbage.
TX-LTE-WLAN
© Hans Turck GmbH & Co. KG | 100028823 2021-06 DE EN FR
