TOPMAQ TW08 MINI, Operation & Maintenance Manual

Page: 34 / 52

34
1. Manually loosen the drain plug at bottom of
oil-water separator.
2. After the draining, manually tighten the drain to
ensure no leakage of oil or air.
Caution: after the draining, make sure air is drained out
of fuel system to make sure the engine could start up
normally.
Electrical system - battery
I. Check the battery electrolyte level and the terminals.
Caution: gas inside the battery may explode. Therefore, keep any spark or flame away from battery.
Use a flashlight to check the electrolyte level. In addition, the sulphuric acid in the battery electrolyte is toxic and
can burn your skin, clothes or even cause blindness.
Therefore, take the following steps to avoid any risk:
1. Refilling of the battery should be done in a well-ventilated area.
2. Wear on goggles and plastic gloves.
3. Care must be taken not to spray out the electrolyte.
4. Use the proper measures to assist battery startup.
If you contact battery acid:
1. Rinse the skin with clean cold water.
2. Use soda or lime to neutralize the acid.
3. Rinse eyes for 10 - l5 min and then go to your doctor.
Caution:
a. Always disconnect the battery clips (-) away from the ground and then connect it to the terminals.
b. Always keep the terminals at the top of the battery and the breather clean to avoid the battery from
discharging. Check if the battery terminal is loose or rusted. Coat the terminals with vaseline to avoid any
corrosion.