Thermos 461240504, Product Manual

Page: 19 / 28

461240504 • 19
WARNING
Safety Tips
s
s
s
s
s
s
s
s
s
s
Before opening LP tank valve, check the coupling nut for
tightness.
When grill is not in use, turn off all control knobs and LP tank
valve.
Never move grill while in operation or still hot.
Use long-handled barbecue utensils and oven mitts to avoid
burns and splatters.
Maximum load for sideburner and side shelf is 10 lbs.
The grease receptacle be attached to grease tray and
emptied after each use. Do not remove grease receptacle
until grill has completely cooled.
If you notice grease or other hot material dripping from grill
onto valve, hose or regulator, turn off gas supply at once.
Determine the cause, correct it, then clean and inspect valve,
hose and regulator before continuing. Perform a leak test.
Keep ventilation openings in cylinder enclosure (grill cart) free
and clear of debris.
The regulator may make a humming or whistling noise during
operation. This will not affect safety or use of grill.
If you have a grill problem see the .
must
"Troubleshooting Section"
CAUTION
• Putting out grease fires by closing the lid is not
possible. Grills are well ventilated for safety reasons.
• Do not use water on a grease fire. Personal injury may
result. If a grease fire develops, turn knobs and LP tank
off.
• Do not leave grill unattended while preheating or
burning off food residue on HI. If grill has not been
regularly cleaned, a grease fire can occur that may
damage the product.
Ignitor Lighting
s
Turn on gas at LP tank.
To ignite, turn center knob to HI, push and hold ELECTRONIC
IGNITOR button.
If ignition does NOT take place within 5 seconds, turn all
burner valves to OFF, wait 5 minutes, then repeat lighting
procedure.
To ignite left burner, turn left knob to HI.
To ignite right burner, turn right knob to HI.
Do not lean over grill while lighting.
1. Open lid.
2.
3.
4.
5.
Lighting instructions continued on next page.
For Safe Use Of Your Grill And To Avoid Serious
Injury:
•
•
•
•
•
•
• Use grill at least 3 ft. from any wall or surface.
• Apartment Dwellers:
• NEVER attempt to light burner with lid closed. A buildup
of non-ignited gas inside a closed grill is hazardous.
• Never operate grill with LP tank out of correct position
specified in assembly instructions.
• Always close LP tank valve and remove coupling nut
before moving LP tank from specified operation
position.
Do not let children operate or play near grill.
Keep grill area clear and free from materials that burn.
Do not block holes in bottom or back of grill.
Check burner flames regularly.
Use grill only in well-ventilated space. NEVER use in
enclosed space such as carport, garage, porch, covered
patio, or under an overhead structure of any kind.
Do not use charcoal or ceramic briquets in a gas grill.
(
Maintain
10 ft. clearance to objects that can catch fire or sources of
ignition such as pilot lights on water heaters, live electrical
appliances, etc..
Check with management to learn the requirements and fire
codes for using an LP gas grill in your apartment complex. If
allowed, use outside on the ground floor with a three (3) foot
clearance from walls or rails. Do not use on or under
balconies.
Unless briquets are supplied with your grill.)