57
ALERT CONDITIONS
:KHQWKHFRQWUROV\VWHPGHFODUHVDQ$OHUWFRQGLWLRQLWZLOOGLVSOD\
DQ$OHUWPHVVDJHRQWKHFRQWUROV\VWHPV/&'ZLWKDTXHVWLRQ"
PDUN7KHZDWHUKHDWHUZLOOFRQWLQXHWRRSHUDWHGXULQJDQ$OHUW
FRQGLWLRQ EXW WKH ZDWHU KHDWHU PXVW EH VHUYLFHG E\ D TXDOL¿HG
VHUYLFHDJHQWDVVRRQDVSRVVLEOH
RESETTING CONTROL SYSTEM LOCK OUTS
7R UHVHW WKH FRQWURO V\VWHP IURP D ORFN RXW FRQGLWLRQ WXUQ WKH
SRZHUVXSSO\RIIIRUDSSUR[LPDWHO\VHFRQGVDQGWKHQEDFNRQ
.HHSLQPLQGLIWKHFRQGLWLRQWKDWFDXVHGWKH)DXOWKDVQRWEHHQ
FRUUHFWHGWKHFRQWUROV\VWHPZLOOFRQWLQXHWRORFNRXW
DIAGNOSTIC CHECKS
Turn off power to the water heater
before performing any service.
Electrical Shock Hazard
Label all wires prior to disconnecting
when performing service. Wiring errors
can cause improper and dangerous
operation.
Verify proper operation after servicing.
Failure to follow these instructions can
result in personal injury or death.
7KHIROORZLQJVHFWLRQ)DXOW$QG$OHUW0HVVDJHVRQSDJHOLVWV
VRPHRIWKHPHVVDJHVWKHFRQWUROV\VWHPZLOOGLVSOD\RQWKH/&'
ZKHQWKHUHDUHRSHUDWLRQDOSUREOHPV7KLVLVQRWDFRPSOHWHOLVW
$ORQJZLWKHDFKRIWKH)DXOWDQG$OHUWPHVVDJHVGHVFULEHGWKHUH
ZLOOEHDOLVWRISRVVLEOHFDXVHVDQGWKLQJVWRFKHFNDQGUHSDLU
2QO\ TXDOL¿HG VHUYLFH DJHQWV DV GH¿QHG LQ 4XDOL¿FDWLRQV RQ
SDJH XVLQJ DSSURSULDWH WHVW HTXLSPHQW VKRXOG SHUIRUP DQ\
VHUYLFHSURFHGXUHVRQWKHZDWHUKHDWHU
NOTE:
,I \RX DUH QRW TXDOL¿HG DQG OLFHQVHG RU FHUWL¿HG DV
UHTXLUHGE\WKHDXWKRULW\KDYLQJMXULVGLFWLRQWRSHUIRUPDJLYHQ
WDVNGRQRWDWWHPSWWRSHUIRUPDQ\RIWKHGLDJQRVWLFRUVHUYLFH
SURFHGXUHVGHVFULEHGLQWKHIROORZLQJVHFWLRQ
,I\RXGRQRWXQGHUVWDQGWKHLQVWUXFWLRQVLQWKHIROORZLQJVHFWLRQ
GRQRWDWWHPSWWRSHUIRUPDQ\SURFHGXUHV
&DOOWKHWHFKQLFDOVXSSRUWSKRQHQXPEHUOLVWHGRQWKHEDFNFRYHU
RI WKLV PDQXDO IRU IXUWKHU WHFKQLFDO DVVLVWDQFH RU WR ORFDWH D
TXDOL¿HGVHUYLFHDJHQWLQ\RXUDUHD
Jumping out control circuits or components can
result in property damage, personal injury or death.
Service should only be performed by a qualified service
agent using proper test equipment.
Altering the water heater controls and/or wiring in any way
could result in permanent damage to the controls or water
heater and is not covered under the limited warranty.
Any bypass or alteration of the water
heater controls and/or wiring will result
in voiding the appliance warranty.
Altering the water heater controls and/or wiring in any way
could result in altering the ignition sequence allowing gas to
flow to the main burner before the hot surface igniter is at
ignition temperature causing delayed ignition which can
cause a fire or explosion.
&ROGHULQFRPLQJZDWHUWHPSHUDWXUHOHQJWKHQLQJWKHWLPH
UHTXLUHGWRKHDWZDWHUWRGHVLUHGWHPSHUDWXUH
+RWZDWHUSLSLQJOHDNVRSHQIDXFHWVZDWHUKHDWHUGUDLQ
valve leaking or open.
6HGLPHQWRUOLPHVFDOHDFFXPXODWLRQPD\EHDIIHFWLQJZDWHU
KHDWHURSHUDWLRQ6HH0DLQWHQDQFHRQSDJHIRUVHGLPHQW
DQGOLPHVFDOHUHPRYDOSURFHGXUHV
:DWHUKHDWHUQRW¿ULQJDWIXOOLQSXWUDWLQJ&KHFNPDQLIROG
JDVSUHVVXUHVHHLQVWUXFWLRQVRQSDJH&KHFNDFWXDO¿ULQJ
UDWHRIWKHZDWHUKHDWHUVHHLQVWUXFWLRQVRQSDJH
WATER IS TOO HOT
Operating Set Point is set too high. See Operating Set Point
$QG'LIIHUHQWLDO$GMXVWPHQWRQSDJH
8SSHUDQGRU/RZHU3UREH2IIVHWVHWWLQJVLPSURSHUO\VHW
VHH7HPSHUDWXUHV0HQXFRQWRQSDJH
,PSURSHUZDWHUSLSLQJVHHGLDJUDPVEHJLQQLQJRQSDJH
NOISY OPERATION
6HGLPHQWRUOLPHVFDOHDFFXPXODWLRQVFDQFDXVHUXPEOLQJ
DQGSRXQGLQJQRLVHVGXULQJKHDWLQJF\FOHV6HHWKH
0DLQWHQDQFHVHFWLRQRIWKLVPDQXDOEHJLQQLQJRQSDJHIRU
VHGLPHQWDQGOLPHVFDOHUHPRYDOSURFHGXUHV
1RUPDORSHUDWLQJQRLVHRIHOHFWULFDOFRPSRQHQWV
&RPEXVWLRQ%ORZHUWUDQVIRUPHUKXPUHOD\FRQWDFWFORVXUH
WATER LEAKAGE IS SUSPECTED
(QVXUHWKHZDWHUKHDWHUGUDLQYDOYHLVWLJKWO\FORVHG
&KHFNFOHDQRXWRSHQLQJIRUOHDNVVHH)LJXUHRQSDJH
&KHFNLQOHWRXWOHWZDWHUFRQQHFWLRQVDQGV\VWHPSLSLQJ
&KHFNWKH7HPSHUDWXUH3UHVVXUH5HOLHI9DOYH
([FHVVLYHZDWHUWHPSHUDWXUH
([FHVVLYHZDWHUSUHVVXUH
'HIHFWLYH7HPSHUDWXUH3UHVVXUH5HOLHI9DOYH
NOTE:
([FHVVLYHZDWHUSUHVVXUHLVWKHPRVWFRPPRQFDXVHRI
7HPSHUDWXUH3UHVVXUH 5HOLHI 9DOYH OHDNDJH ([FHVVLYH ZDWHU
V\VWHP SUHVVXUH LV PRVW RIWHQ FDXVHG E\ WKHUPDO H[SDQVLRQ
LQDFORVHGV\VWHP6HH7KHUPDO([SDQVLRQDQG&ORVHG:DWHU
Systems on page 14. The Temperature-Pressure Relief Valve is
QRWLQWHQGHGIRUWKHFRQVWDQWUHOLHIRIWKHUPDOH[SDQVLRQ
7HPSHUDWXUH3UHVVXUH5HOLHI9DOYHOHDNDJHGXHWRSUHVVXUHEXLOG
XSLQDFORVHGV\VWHPWKDWGRHVQRWKDYHDWKHUPDOH[SDQVLRQ
WDQNLQVWDOOHGLVQRWFRYHUHGXQGHUWKHOLPLWHGZDUUDQW\7KHUPDO
H[SDQVLRQWDQNVPXVWEHLQVWDOOHGRQDOOFORVHGZDWHUV\VWHPV
REPLACEMENT PARTS
5HSODFHPHQW SDUWV PD\ EH RUGHUHG IURP WKH PDQXIDFWXUHU
DXWKRUL]HGVHUYLFHDJHQFLHVRUGLVWULEXWRUV:KHQRUGHULQJSDUWV
EHVXUHWRKDYHWKHFRPSOHWHZDWHUKHDWHU0RGHO1XPEHU6HULDO
1XPEHUDQG6HULHV1XPEHUDYDLODEOH7KLVLQIRUPDWLRQFDQEH
IRXQGRQWKHUDWLQJODEHODI¿[HGWRWKHZDWHUKHDWHU
5HIHU WR WKH SDUWV OLVW LQFOXGHG ZLWK WKH ZDWHU KHDWHU IURP WKH
IDFWRU\ IRU PRUH LQIRUPDWLRQ RU FDOO WKH SDUWV GHSDUWPHQW RU
WHFKQLFDOVXSSRUWSKRQHQXPEHUOLVWHGRQWKHEDFNFRYHURIWKLV
PDQXDOIRUIXUWKHUDVVLVWDQFH
FAULT AND ALERT CONDITIONS
FAULT CONDITIONS
:KHQWKHFRQWUROV\VWHPGHFODUHVD)DXOWFRQGLWLRQLWZLOOGLVSOD\
D)DXOWPHVVDJHRQWKHFRQWUROV\VWHPV/&'ZLWKDQH[FODPDWLRQ
PDUN 7KH FRQWURO V\VWHP ZLOO ORFN RXW DQG GLVDEOH KHDWLQJ
RSHUDWLRQXQWLOWKHFRQGLWLRQLVFRUUHFWHG7KHZDWHUKHDWHUPXVW
EHVHUYLFHGE\DTXDOL¿HGVHUYLFHDJHQWEHIRUHRSHUDWLRQFDQEH
UHVWRUHG
