SSR Motorsports srz800, Owner'S Manual, Page: 16 / 19

15
TROUBLESHOOTING GUIDE
Problem Possible cause Solution
Vehicle does not run.
Speed Control Switch in
OFF position
Select the LOW or HIGH position on the speed control
switch.
Undercharged battery.
Charge the battery. A new battery should have been
charged for at least 12 hours before using the vehicle
for the first time and up to 8 hours after each
subsequent use.
Check all connectors. Make sure the charger
connector is tightly plugged into the charging port, and
that the charger is plugged into the wall.
Make sure power flow to wall outlet is on.
Charger is not working.
You may check to see if your charger is working by
using a volt meter or asking the authorized service
center to test your charger for you.
Vehicle was running
but suddenly stopped.
Loose wires or connectors.
Check all wires and connectors to make sure they are
tight.
Burned-out fuse.
The fuse will burn out and automatically shut off the
power if the motor is overloaded.
An excessive overload could cause the motor to
overheat. Refer to replacing the fuse instructions of
this manual. Correct the conditions that caused the
fuse to burn out and avoid repeatedly burning out fuse.
Motor or electrical switch
damage.
Contact the authorized service center for diagnosis
and repair.
Short run time less than
15 minutes per charge
Undercharged battery
Charge the battery. A new battery should have been
charged for at least 12 hours before using the vehicle
for the first time and up to 8 hours after each
subsequent use.
Check all wires and connectors. Make sure the battery
connector is tightly plugged into the charger connector,
and that the charger is plugged into the wall.
Make sure power flow to the wall outlet is on.
Battery is old and will not
accept full charge.
Even with proper care, a rechargeable battery does
not last forever. Average battery life is 1 to 2 years
depending on vehicle use and conditions. Replace
only with the correct type of replacement battery.
Brakes may be dragging. See your dealer or a qualified technician.