Repair leak. Check suction pipe,
see-through lid in place? O-ring clean?
Remove blockage or increase suction
pipe size. Make sure strainer tank is
clean. Are all suction valves fully open?
Disassemble pump and remove foreign
matter from impeller.
Improve suction conditions. (Reduce
suction lift, reduce number of fittings,
increase pipe size.) Increase discharge
pressure and reduce flow by throttling
discharge valve.
Check wiring diagram on motor.
Check with volt meter. Increase size of
supply wire. Report low supply voltage to
power company. Voltage at motor must be
within 10% of motor nameplate voltage.
Heaters should be one size larger than full
load amps shown on motor nameplate.
Indicated by high amperage readings on
motor, binding shaft. Disassemble unit
and correct.
a. Air leak in suction line. Bubbles
in water returning to pool at inlet.
b. Restricted suction line due to
blockage or undersize pipe.
Indicated by high vacuum
reading at pump suction.
c. Foreign matter (gravel, metal,
etc.) in pump impeller.
d. Cavitation.
a. Motor is not connected properly.
b. Low voltage due to undersize
wire or low incoming voltage.
c. Wrong size heaters
in protective device.
d. Overload due to binding in
pump or wrong size impeller.
PROBLEM
POSSIBLE CAUSES
SOLUTION
6. Noisy operation of pump.
7. Motor overload protection
“kicks out.”
SAVE THESE INSTRUCTIONS!
LIMITED WARRANTY
The pump and motor are warranted to be free from defects in material
and workmanship for a period of twenty-four (24) months from the
date that the pump is originally installed.
Notwithstanding any provision herein to the contrary, the
warranties and obligations hereunder shall not in any event extend for
more than 3 years beyond the date of shipment of the motor and the
pump from the factory in Jacksonville, Florida.
Warranty is void in the following cases: damages which result in whole
or in part from: (a) careless or improper installation of the pump or the
motor; b) Improper or negligent use and maintenance of the pump or
the motor; (c) tampering with the pump or the motor by unauthorized
repair personnel.
The manufacturer’s sole obligation hereunder shall be to replace or
repair any defective pump or motor. The manufacturer reserves the
absolute right to determine whether any defective pump or motor
should be replaced or repaired.
Any customer who wishes to make a claim under this
Limited Warranty shall notify the manufacturer of such claim by
telephone or by mail. After the customer has been authorized to
return a defective pump or motor, the customer must return the pump
or motor to the manufacturer at 8125 Bayberry Road, Jacksonville,
Florida 32256. Any goods returned to the manufacturer without
prior authorization will be returned to the shipper unopened. The
manufacturer shall not bear any costs or risks incurred In shipping a
defective pump or motor to the manufacturer or in shipping a repaired
or replaced pump or motor to a customer.
The manufacturer will charge customers for all nonwarranty work
which it may perform. Warranty work will not be performed until the
customer has accepted the price quoted.
EXCEPT AS SPECIFICALLY SET FORTH ABOVE, NO OTHER
WARRANTIES, WHETHER EXPRESSED OR IMPLIED, INCLUDING,
WITHOUT LIMITATION, THE IMPLIED WARRANTIES OF
MERCHANTABILITY AND FITNESS FOR A PARTICULAR
PURPOSE, ARE MADE BY THE MANUFACTURER. IN NO EVENT
WILL THE MANUFACTURER BE LIABLE FOR ANY LOSS,
INCLUDING TIME, MONEY, GOODWILL, LOST PROFITS AND
CONSEQUENTIAL DAMAGES BASED ON CONTRACT, TORT OR
OTHER LEGAL THEORY, WHICH MAY ARISE HEREUNDER OR
FROM THE USE, OPERATION OR MODIFICATION OF THE PUMP,
MOTOR OR ASSOCIATED PARTS, THE MAXIMUM LIABILITY OF
THE MANUFACTURER HEREUNDER SHALL NOT EXCEED THE
AMOUNT ACTUALLY PAID BY THE CUSTOMER FOR THE PUMP,
MOTOR, AND ASSOCIATED PARTS.
Some states do not permit limitations on the terms of implied
warranties or on the recovery of incidental or consequential
damages. Accordingly, the limitations contained in paragraph 7 may
not apply to certain customers.
This warranty gives customers specific legal rights. Customers may
have other rights which vary from state to state.
1.
2.
3.
4.
5.
6.
7.
8.
9.
Date of Installation____________________ Installed By__________________________ For Service Call________________________________
The manufacturer supplies a limited warranty to the original
consumer purchaser of the pump and the motor on the following
terms and conditions:
REV. 041907 - Model 93
2999999926
