User Manual
// Simpro Ezi-MT
Original Instructions // English // v40.0 // October 2022 // Page 24
Crushing due to machine falling over
Operator
LO:
1
FE:
4
DPH:
8
NP:
1
Risk Factor:
32
Low risk as the machine is very stable and the bin centre of gravity remains well
’ f u u y
Other
persons
LO:
1
FE:
1
DPH:
8
NP:
1
Risk Factor:
8
As above.
Control
measures
Do not operate the machine on soft or uneven ground, or ground with a slope
ratio greater than 1:12.
Never attempt to empty liquids from closed-top drums.
Comments
Illness caused by tipping toxic powder and liquid
Operator
LO:
1
FE:
4
DPH:
1
NP:
1
Risk Factor:
4
The operator may be exposed to liquids or powders being tipped, especially in
windy conditions. If the product could cause any harm whatsoever to the
operator or to any other person, all persons must wear suitable Personal
Protective Equipment.
Other
persons
LO:
0.5
FE:
4
DPH:
1
NP:
2
Risk Factor:
4
As above.
Control
measures
The operator is responsible to wear appropriate Personal Protective Equipment,
and ensure that all other persons are well clear of the area.
Powder should only be tipped in calm conditions, or a wind shield should be
installed.
Comments
Toxic substances that cannot be protected against with PPE should not be
dumped using an Ezi-MT. Alternative methods should be used.
Repetitive Strain Injury (RSI) caused by excessive winch operation
Operator
LO:
2
FE:
2.5 DPH:
4
NP:
1
Risk Factor:
20
The operator may feel pressured to use the machine excessively to keep up
with higher-than-normal waste flows.
Other
persons
LO:
0.1
FE:
0.1 DPH:
1
NP:
1
Risk Factor:
0
Little or no risk
Control
measures
Operators must be trained in safe operating procedures, including duty cycle
limitations, before being authorised to use the machine.
Comments
See
for Ezi-MT duty cycle limitations.
Damage to skin when used in extreme weather conditions
Operator
LO:
2
FE:
4
DPH:
1
NP:
1
Risk Factor:
8
If the machine is to be used in extreme cold or heat, the operator must wear
gloves and other suitable Personal Protective Equipment.
Other
persons
LO:
2
FE:
2
DPH:
1
NP:
1
Risk Factor:
4
As above.
Control
measures
Operators are responsible to wear Personal Protective Equipment suitable for
the environment in which the machine is being used.
Comments
See
for Ezi-MT environmental restrictions.
Summary of Contents for Ezi-MT
