53
SQUEEGEE SP300 & SP300 DUAL/SPRAY
APPLIES TO: SP 300 AND SP 300 DUAL
HOW TO WINTERIZE YOUR EQUIPMENT
1.
If the machine has been in use, add water to the tank and let it agitate
at a high speed for 30 minutes. Pump this water through the spray
wand. When the tank is empty, make a 50/50 mixture of RV antifreeze
and water approximately 4-gals, and pour this into the tank. Turn on
the material pump and open the spray wand until the mixture starts
to come out. Open the recirculation valve for a brief moment, then
close it. Do this to all the valves. The entire pumping system is now
protected from freezing.
2.
If you have a water tank, spray bar, water pump, and fog spray, run
RV antifreeze thru these also.
3.
Disconnect the battery and take it inside. A battery charging
maintainer will assure that it lasts through the off-season.
4.
Cover the engine with a plastic bag.
5.
Cover the cap on the hydraulic tank, also around each locking cap.
6.
If any cylinder rods are exposed, put a thin layer of grease on them.
7.
In the winter, when the temperature is below freezing, get inside of
the tank with proper hearing protection and an air chipping gun with a
1” spade bit and chip off all remaining sealer from the walls and
paddles.
NOTE
: If you don’t do this, the dried material will come off all
during the season causing the basket strainer and spray tips to plug.
8.
In the spring totally flush all the antifreeze from the system.
Summary of Contents for SP 300
Page 1: ......
Page 27: ...25 HYDRAULIC FLOW CHART ...
Page 41: ...39 SQUEEGEE SP300 DUAL SPRAY SANDPUMPER II SANDPUMPER II ...
