INSTRUCTIONS FOR
ROADSTART EMERGENCY POWER PACKS
MODEL NO’S:
RS131.V3, RS132
Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these
instructions, and properly maintained, give you years of trouble free performance.
IMPORTANT:
PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE
THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR
PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.
1. SAFETY
IMPORTANT:
To reduce the risk of a battery explosion, follow these instructions and those published by the battery manufacturer and the
manufacturer of any equipment you intend to use in the vicinity of the battery. Remember to review warning marks on all products and on
engines.
1.1.
PERSONAL PRECAUTIONS
Ensure there is another person within hearing range, or close enough to come to your aid should a problem arise, when working
near a lead-acid battery.
Have fresh water and soap nearby in case battery acid contacts skin, clothing or eyes.
Wear safety eye protection and protective clothing. Avoid touching eyes while working with a battery.
Wash immediately with soap and water if battery acid contacts skin or clothing. If acid enters eye, flush eye immediately with cool,
clean running water for at least 15 minutes and seek immediate medical attention.
Remove personal metallic items such as rings, bracelets, necklaces and watches. A lead-acid battery can produce a short-circuit
current high enough to weld a ring or the like to metal, which may cause severe burns.
1.2.
IMPORTANT SAFETY INSTRUCTIONS
Familiarise yourself with the applications, limitations and potential hazards of the RoadStart.
Keep the unit in good working order and condition. Replace damaged parts immediately.
Use only recommended parts. To use unapproved parts may be dangerous and will invalidate your warranty.
The RoadStart must only be opened and checked by qualified service personnel.
DO NOT
disassemble the unit for any reason.
Keep children and unauthorised persons away from the work area.
Keep work area clean and tidy and free from unrelated materials. Ensure that there is adequate lighting.
If the RoadStart receives a sharp knock or blow, it must be checked by a qualified service agent before being used.
When not in use re-charge every two months.
DO NOT
smoke or allow a spark, or flame in the vicinity of the battery or engine.
DO NOT
drop any metal item onto the battery as it may spark or short circuit the battery, which could cause an explosion.
DO NOT
use RoadStart to recharge dry cell batteries that are commonly used with home appliances. These batteries may explode and
cause personal injury and damage to property.
DO NOT
charge or boost a frozen battery.
DO NOT
use attachments other than those recommended. To do so may risk damage to the unit and other equipment and possible
personal injury.
DO NOT
pull or carry the unit by its cables and do not pull the negative and positive clamps from the battery terminals.
DO NOT
operate in vicinity of flammable liquids or gases.
DO NOT
recharge the unit with plugs, cables or attachments that are damaged. Replace such items immediately.
DO NOT
use this product to perform a task for which it is not designed.
DO NOT
store the unit in damp or wet locations or where the temperature may exceed 50°C.
DO NOT
submerge the unit in water.
Refer to
Instruction
Manual
Warning:
Explosive
Material
Warning:
Corrosive
substance
Wear eye
Protection
RS131.V3 RS132 | Issue 5(I) 04/01/16
Original Language Version
© Jack Sealey Limited
IMPORTANT WARRANTY INFORMATION: KEEP YOUR ROADSTART HEALTHY
Read and understand the general safety and operating instructions before use. The following information is intended to help you
keep the product in top working order.
NOTE – The battery in this unit is a consumable item and its ability to accept charge will reduce over time. We will warranty it
against mechanical and electrical defect for a period of one year - this does not cover fair wear and tear.
If the battery is not properly charged before first use, or regularly conditioned, its capacity will diminish. Under these circumstances we will
not replace the battery even if it is less than one year old.
You can help prolong the lifecycle of the battery by following a few simple guidelines.
•
Plug in your new Roadstart to the mains transformer and make an INITIAL charge lasting 38 hours.
•
Ensure the unit is fully charged before storage.
•
DO NOT
leave the Roadstart for longer than 2 months without putting it on charge.
•
DO NOT
attempt to start a vehicle when the Roadstart battery voltage is reduced to less than 7Volts.
•
DO NOT
drop or roughly handle the Roadstart – this will break or disjoin the battery terminals rendering the battery useless and the
warranty void.
•
DO NOT
use any other charger, other than the one supplied, to recharge the battery.
Wear
Protective
Gloves
Warning:
Electricity
Protect
From
Rain
Use in
Well
Ventilated
Areas
Keep away
from sources
of ignition:
Battery could
explode
