16
Hoist
does not Raise or Lower
Does hoist rotate?
Yes.
1. Check connection to Control Box. Be sure plug is pushed in all the way.
2. Check hand control connection to Control Box for damaged pins.
3. Check connection cable for damage.
4. Activate the up and down buttons on the front panel of the control box. If hoist raises
and lowers, the problem is likely the hand control.
5. If the hoist does not raise and lower when using the buttons on the control box,
reverse the cables as follows: Locate the area on the Control Box where the cables
are attached. Swap the actuator cable from the connector #2 and the 24v motor
cable from connector #1. Activate the left and right buttons on the hand control. If the
hoist raises and lowers, the problem is likely the hand control. If the hoist does not
raise and lower, the problem is likely the Actuator.
6. Contact your Authorized Reseller or S.R. Smith for component replacement
information.
Does hoist rotate?
No.
1. Check battery charge level.
2. Check battery connection.
3. Use another fully charged battery. If hoist does not function, replace the Control Box.
LONG-TERM STORAGE
When storing the hoist for an extended period of time:
•
Wash seat with disinfectant solution and then rinse with fresh water and dry entire hoist
•
Spray gear assembly with a heavy-duty rust inhibitor and lubricant such as LPS 3
•
Keep the battery on the charger in a dry temperature controlled area
•
Cover unit and store in a dry location away from pool chemicals
CUSTOMER CARE
Customers are encouraged to read and obey all of the user instructions listed in this manual whenever
using the hoist. Comply with all Caution, Warning, Operating Instructions and Labels located on the hoist.
If the hoist will be used by a disabled person independently, a communication device should be available
in the area in the event of an emergency. Only persons healthy enough for water activities should use the
hoist. Users should consult with their physician to determine if water activities are appropriate for their
condition. Keep fingers and hands clear of hoist arms or pinch points during use.
In the event of a malfunction of the hoist or serious incident to a user, contact SR Smith at 1-800-824-
4387 or email at [email protected].
