Rugby MONARCH, Installation & Operation Manual

Page: 19 / 21

Stock#: 1657447 (036226)
19
Operation Instructions
WARNING: Being under or near a raised body can result in injury or death should the
body unexpectedly descend or tip. Hoist must be activated with operator in control at a
safe location. No one must be allowed to enter the area under a raised body while the
hoist is in operation.
WARNING:
Being under a raised body can result in serious injury or death should the
body unexpectedly descend. Never position yourself or allow other to position
themselves under a loaded body. Always prop the unloaded body up using the body
prop or body props supplied.
Remember
body props are to be used only on an
unloaded
body. When two props are provided, both props must be used.
DANGER:
1. Stay out from under body when hoist is operating.
2. During dumping operations, no one must be allowed to stand in or move
through the area where the body and hoist operate or into an area where an
upset load might fall.
3. Controls must be in a safe location and operator must remain at controls
during dumping operation. Controls must be located in a location where it
is not possible to be under body during dumping operation.
4. Never leave body raised or partly raised while the truck or trailer is
unattended or while performing maintenance or service under body, unless
body is braced to prevent accidental lowering.
5. Do not attempt to raise a loaded body when the truck or trailer is on un-
level ground.
6. Never jerk or shock a raised body to loosen a stuck load.
WARNING: Freeing a stuck load during dumping, with the body raised, by jerking or
shocking the trailer, may cause damage to the truck or trailer, serious injury or death.
Never drive forward or rearward and stop quickly with the load up or otherwise shock
the load. If a load is stuck in the body, lower the body, then free the load.
WARNING:
Attempting to dump a load on un-level ground may cause the truck or
trailer to over turn, and can result in damage, serious injury or death. Always dump the
load on ground that is level front to rear as well as level side to side.
WARNING: Overloading a hoist can cause component damage or an accident which
may cause injury or death. Never exceed the hoist’s rated lift capacity.
WARNING: Damaged or malfunctioning equipment may cause injury or death. Repair
or replace any damaged or malfunctioning equipment before continuing its use.