4
❑
Battery Care and Disposal
Do not store the battery in temperatures above 75° or below -10° F.
CONTAINS SEALED LEAD BATTERY. BATTERY MUST BE RECYCLED.
Disposal:
Your Razor product uses sealed lead-acid batteries which must be recycled or disposed of in an
environmentally sound manner. Do not dispose of a lead-acid battery in a fire. The battery may explode or leak. Do not
dispose of a lead-acid battery in your regular household trash. The incineration, land filling or mixing of sealed lead-
acid batteries with household trash is prohibited by law in most areas. Return exhausted batteries to a federal or state
approved lead-acid battery recycler or a local seller of automotive batteries. If you live in Florida or Minnesota, it is
prohibited by law to throw away lead-acid batteries in the municipal waste stream.
❑
Charger
The transformer/charger supplied with the Dune Buggy should be regularly examined for damage to the cord, plug,
enclosure and other parts, and, in the event of such damage, the bike must not be charged until it has been repaired or
replaced.
Use ONLY with the recommended charger.
❑
Replacement Parts
The most frequently requested replacement parts (wheels, tires, tubes, batteries and chargers) are available for
purchase at some Razor retail partners or online at www.razorama.com. For other parts contact an authorized Razor
repair center.
❑
Repair Centers
For a list of authorized Razor repair centers:
• Check online at www.razor.com.
• Send e-mail to [email protected] or call 866-467-2967 for the center nearest you.
WARNING:
If a battery
leak develops, avoid contact with
the leaking acid and place the
damaged battery in a plastic bag.
Refer to the disposal instructions at
left. If acid comes into contact with
skin or eyes, flush with cool water
for at least 15 minutes and contact
a physician.
REPAIR AND MAINTENANCE
Vehicle does not run
Vehicle was running but
suddenly stopped
TROUBLESHOOTING GUIDE
Problem
Possible Cause
Solution
Vehicle is rolling backwards
Undercharged battery
Charger is not working
Loose wires or connectors
Burned-out fuse
Motor or electrical switch damage
Throttle will not engage if the vehicle is rolling backwards. Come to a
complete stop and then activate the throttle.
Charge the battery. A new battery should have been charged for at
least 12 hours before using the vehicle for the first time and up to 8
hours after each subsequent use.
Check all connectors. Make sure the charger connector is tightly
plugged into the charging port, and that the charger is plugged into
the wall.
Make sure power flow to the wall outlet is on.
You may check to see if your charger is working by using a volt meter
or asking your local Razor authorized service center to test your
charger for you.
Check all wires and connectors to make sure they are tight.
The fuse will burn out and automatically shut off the power if the
motor is overloaded.
An excessive overload, such as too heavy a rider or too steep a
hill, could cause the motor to overheat. Refer to replacing the fuse
instructions in this manual. Correct the conditions that caused the
fuse to burn out and avoid repeatedly burning out fuse.
Contact your local Razor authorized service center for diagnosis and
repair.
Summary of Contents for DUNE BUGGY 25143511
Page 9: ...8 DUNE BUGGY PARTS...
