PIPER CHEROKEE SIX / LANCE SERVICE MANUAL
03/27/08
IV - STRUCTURES
1E9
4-7a. WING REAR ATTACH FITTINGS
NOTE: The following procedure is general in nature. Actual removal of the wing rear attach fittings
may require more extensive disassembly. Refer to the Illustrated Parts Catalog, P/N 753-689, for
additional parts, as required, and to assess the job before beginning.
a.
Removal:
1.
Remove electrical power from aircraft by disconnecting the battery.
2.
Place jacks under wings and tail tie-down to stabilize aircraft. Provide support for fuselage in
effected area.
3.
Remove seats, interior panels and center floorboard to gain access to rear wing attach fittings.
4.
Remove or relocate systems components to gain access to the attach fittings.
5.
Remove bolt that attaches fuselage to wing spar.
6.
Carefully remove rivets, screws, inner panels, channels and brackets necessary to remove
attach fitting.
NOTE: In order to remove some channels, it may be necessary to remove the wing(s).
b.
Cleaning, Inspection, and Repair:
1.
Clean and inspect the areas that were under bracket for any signs of corrosion.
2.
If corrosion is found, repair or replace parts as necessary. Coat the area with primer and allow
to dry.
3.
If no corrosion is found, coat the area with primer. Allow time to dry.
c.
Installation:
1.
Install new wing attach fitting and align rivet holes. It may be necessary to ream open the bolt
hole to proper size. The hole is close tolerance and should be .3115 / .3135 (5/16) or .3745 /
.3765 (3/8) depending on model and year. Replace attach fitting bolt should there be any sign
of wear or corrosion.
2.
Re-rivet wing attach fitting into place with appropriate fasteners.
NOTE: For hard to reach areas, it is permissible to replace the existing MS20470AD-5 rivets
with Hi Lok fasteners. Use HL30-5 with HL-94 Hi Lok collars. Torque to 15 to 25 in.-
lbs. Observe standard practices for use of Hi Lok fasteners.
3.
Install wing spar and fuselage attach fitting bolt per the appropriate section of the Maintenance
Manual.
4.
Seal the edges of the attach fittings with (PRC) PR1422 (or equivalent) before installing
interior.
5.
Complete the same process to the opposite side.
6.
Reinstall center floorboard, interior panels, and seats. Connect battery and check for operation.
Summary of Contents for Cherokee LANCE
